Dimensioning of an Anaerobic Digester for the Treatment of Chicken Manure and for the Production of Biogas: The Case Study of a Chicken Farm in Yaokokoroko (Côte d’Ivoire)

This study allowed us to highlight the level of pollution of a BAYA River water near several poultry farms and the sizing of an anaerobic digester that will be able to treat chicken manure from a poultry farm (BRIN FOUNDATION). To evaluate this pollution, the parameters such as ammonium (NH4+), Phosphate (PO43-), Biochemical Oxygen Demand (DBO5) and Nitrate (NO3-) were determined. For sampling point P1, the concentrations in mg/L of these parameters are (25.00 ± 4.25), (0.40 ± 0.20), (98.00 ± 6.35) and (96.00 ± 5.35), respectively. On the other hand, for sampling point P2, the concentrations in mg/L of these parameters are respectively (33.00 ± 9.05), (0.70 ± 0.12), (123 ± 7.13) and (93 ± 7.10). These values indicate a strong organic pollution of the BAYA River. The determination of the different concentrations of the organic pollution parameters allowed us to evaluate the degradation and the quality of the water of the BAYA River water, by the poultry activity. However, considering the physicochemical properties of the waste (chicken manure), which is the main source of organic pollution, we have considered an energy recovery through the production of biogas. This requires the design, sizing, and implementation of an anaerobic digester in a poultry farm. Therefore, the project would require the construction of an adapted masonry type anaerobic digester with a capacity of 10 m3.

Hybrid Donnan dialysiseelectrodialysis for efficient ammonia recovery from anaerobic digester effluent

Ammonia recovery from wastewater is crucial,yet technology of low carbon emission and high ammonia perm-selectivity against complex stream compositions is urgently needed.Herein,a membrane-based hybrid process of the Donnan dialysiseelectrodialysis process(DDeED)was proposed for sustainable and efficient ammonia recovery.In principle,DD removes the majority of ammonia in wastewater by exploring the concentration gradient of NH4 t and driven cation(Nat)across the cation exchange membrane,given industrial sodium salt as a driving chemical.An additional ED stage driven by solar energy realizes a further removal of ammonia,recovery of driven cation,and replenishment of OHtoward ammonia stripping.Our results demonstrated that the hybrid DDeED process achieved ammonia removal efficiency>95%,driving cation(Nat)recovery efficiency>87.1%for synthetic streams,and reduced the OH-loss by up to 78%compared to a standalone DD case.Ammonia fluxes of 98.2 gN m^(-2)d^(-1)with the real anaerobic digestion effluent were observed using only solar energy input at 3.8 kWh kgN^(-1).With verified mass transfer modeling,reasonably controlled operation,and beneficial recovery performance,the hybrid process can be a promising candidate for future nutrient recovery from wastewater in a rural,remote area.

Inhibition mechanisms of ammonia and sulfate in high-solids anaerobic digesters for food waste treatment: Microbial community and element distributions responses

The horizontal flow anaerobic digester indicated that high ammonia (2923 mg/L) and SO42-(3653 mg/L)would influence the performance of methane production with food waste as substrates.Therefore,bottle anaerobic digestion reactors were carried out to investigate the effect of ammonia/sulfate concentrations on the methane production.Experimental results manifested that the anaerobic digesters with an ammonia concentration of 3500 mg/L or sulfate of 1600 mg/L showed the best performance of methane production,with an average methane yield of 0.32 and 0.33 L (g VS)^(-1)d^(-1),respectively.Specifically,a higher ammonia (6500 mg/L) or sulfate (1600-3500 mg/L) level hindered the bioconversion of C from liquid to gas phase (2.68%or 1.73%CH_(4)-Gas,respectively),while insignificantly for the hydrolyzation of C and N from solid to liquid phase.Similar to sulfate,high ammonia nitrogen seriously inhibited the methanation process,leading to a significant carbon accumulation in the anaerobic reactor,especially for propionic acid.The predominant archaea Methanosarcina at genus level indicated that aceticlastic methanogenesis was the major methanogenic pathway.Meanwhile,high ammonia level suppressed the activity of Methanosarcina,while modest sulfate improved H_(2)-consuming methanogens activity.A large fraction of unclassified bacteria within the Firmicutes (43.78%-63.17%) and Bacteroidetes (24.20%-33.30%) phylum played an important role in substrates hydrolysis.

Valorization of poly-β-hydroxybutyrate(PHB)-based bioplastic waste in anaerobic digesters of food waste for bioenergy generation:reactor performance,microbial community analysis,and bioplastic biodegradation

This study aims to investigate the significance and biodegradation pathways of PHB-based bioplastic in anaerobic digesters treating food waste,where the reactor performance of changed methane generation,bioplastic biodegradation efficiency,and bioinformatic analysis of functional microbes were emphasized.The results showed that PHB-based plastic film could be partially biodegraded in the food waste digester,and a bioaugmentation use of Alcaligenes Faecalis(AF)and Bacillus Megaterium(BM)was beneficial to largely accelerate the degradation process through a beneficial shift of both the functional bacterial and archaeal species.Microbial community analysis indicated that the major bacterial species belonged to genera Candidatus_Cloacimonas,Rikenellaceae,and Defluviitoga,while the dominant methanogenic archaeal species belonged to genera Methanomassiliicoccus,Methanosarcina,and Methanosaeta.Bioplastic biodegradation analysis suggested that the optimal fractions of AF and BM for PHB-based plastic degradation were 50% AF and 75% BM,respectively,which deserves further optimization and scale-up validation.The finding of this study would contribute to the combined management of PHB-based bioplastic with food waste for clean energy recovery and a greener environment.

Effects of Potassium Ferrate and Low-Temperature Thermal Hydrolysis Co-Pretreatment on the Hydrolysis and Anaerobic Digestion Process of Waste Activated Sludge

This study evaluated the effect of potassium ferrate(PF)and low-temperature thermal hydrolysis co-pretreatment on the promotion of sludge hydrolysis process and the impact on acid production in the subsequent anaerobic digestion process.The analytical investigations showed that co-pretreatment significantly facilitated the hydrolysis process of the sludge and contributed to the accumulation of short-chain fatty acids(SCFAs).The pretreatment conditions under the optimal leaching of organic matter from sludge were hydrothermal temperature of 75℃,hydrothermal treatment time of 12 h,and PF dosage of 0.25 g g^(−1)TSS(total suspended solids),according to the results of orthogonal experiments.By pretreatment under proper conditions,the removal rate of soluble chemical oxygen demand(SCOD)achieved 71.8%at the end of fermentation and the removal rate of total phosphorus(TP)was 69.1%.The maximum yield of SCFAs was 750.3 mg L^(−1),7.45 times greater than that of the blank group.Based on the analysis of the anaerobic digestion mechanism,it was indicated that the co-pretreatment could destroy the floc structure on the sludge surface and improve organic matter dissolving,resulting in more soluble organic substances for the acidification process.Furthermore,microbial community research revealed that the main cause of enhanced SCFAs generation was an increase in acidogenic bacteria and a reduction of methanogenic bacteria.

Effects of Biowaste-Derived Hydrochar on Anaerobic Digestion:Insights into Hydrochar Characteristics

Hydrochar prepared with four typical biowastes,pine wood,food waste,digested sewage sludge,and Chlorella were applied for the promotion of anaerobic digestion.The gas production and substrate composition were analyzed associated with the hydrochar characteristics.The results suggested that Chlorella hydrochar(C-C)showed the highest cumulative yield of methane(approximately 345 mL)with high total organic carbon(TOC)removal efficiency and low volatile fatty acids(VAFs)concentration.Especially,food waste hydrochar(F-C)showed a poor effect on anaerobic digestion and aroused 1.4–1.6 g/L accumulation of VAFs,in which the toxic components may account for the low efficiency.The C-C and sludge hydrochar(S-C)may develop direct interspecific electron transport(DIET)to facilitate the generation of methane by both surface groups and conductivity of the body structure,unlike pinewood hydrochar(P-C),which mainly depended on the aromatic matrix structure of hydrochar body.This work suggested that C-C can be the best candidate for the facilitation of anaerobic digestion,and N-containing biowaste like algae and lignocellulose like pine wood may establish different DIET pathways based on the physicochemical characteristics of hydrochar.

Effects of ultrasonic pretreatment on sludge dewaterability and extracellular polymeric substances distribution in mesophilic anaerobic digestion

Effect of ultrasonic pretreatment on sludge dewaterability was determined and the fate of extracellular polymeric substances （EPS） matrix in mesophilic anaerobic digestion after ultrasonic pretreatment was studied. Characteristics of proteins （PN）, polysaccharides （PS）, excitation-emission matrix （EEM） fluorescence spectroscopy and molecular weight （MW） distribution of dissolved organic matters （DOM） in different EPS fractions were evaluated. The results showed that after ultrasonic pretreatment, the normalized capillary suction time （CST） decreased from 44.4 to 11.1 （sec·L）/g total suspended solids （TSS） during anaerobic digestion, indicating that sludge dewaterability was greatly improved. The normalized CST was significantly correlated with PN concentration （R2 = 0.92, p 〈 0.01） and the PN/PS ratio （R2 = 0.84, p 〈 0.01） in the loosely bound EPS （LB-EPS） fraction. Meanwhile, the average MW of DOM in the LB- EPS and tightly bound EPS （TB-EPS） fractions also had a good correlation with the normalized CST （R2 〉 0.66, p 〈 0.01）. According to EEM fluorescence spectroscopy, tryptophan-like substances intensities in the slime, LB-EPS and TB-EPS fractions were correlated with the normalized CST. The organic matters in the EPS matrix played an important role in influencing sludge dewaterability.

Start-up performances of dry anaerobic mesophilic and thermophilic digestions of organic solid wastes

Two dry anaerobic digestions of organic solid wastes were conducted for 6 weeks in a lab-scale batch experiment for investigating the start-up performances under mesophilic and thermophilic conditions. The enzymatic activities, i.e., β-glucosidase, N-α-benzoyl-Largininamide （BAA）-hydrolysing protease, urease and phosphatase activities were analysed. The BAA-hydrolysing protease activity during the first 2-3 weeks was low with low pH, but was enhanced later with the pH increase. β-Glucosidase activity showed the lowest values in weeks 1-2, and recovered with the increase of BAA-hydrolysing protease activity. Acetic acid dominated most of the total VFAs in thermophilic digestion, while propionate and butyrate dominated in mesophilic digestion. Thermophilic digestion was confirmed more feasible for achieving better performance against misbalance, especially during the start-up period in a dry anaerobic digestion process.

Characteristics of high-sulfate wastewater treatment by two-phase anaerobic digestion process with Jet-loop anaerobic fluidized bed

A new anaerobic reactor, Jet-loop anaerobic fluidized bed （JLAFB）, was designed for treating high-sulfate wastewater. The treatment characteristics, including the effect of influent COD/SO42 ratio and alkalinity and sulfide inhibition in reactors, were discussed for a JLAFB and a general anaerobic fiuidized bed （AFB） reactor used as sulfate-reducing phase and methane-producing phase, respectively, in two-phase anaerobic digestion process. The formation of granules in the two reactors was also examined. The results indicated that COD and sulfate removal had different demand of influent COD/SO4^2- ratios. When total COD removal was up to 85%, the ratio was only required up to 1.2, whereas, total sulfate removal up to 95% required it exceeding 3.0. The alkalinity in the two reactors increased linearly with the growth of influent alkalinity. Moreover, the change of influent alkalinity had no significant effect on pH and volatile fatty acids （VFA） in the two reactors. Influent alkalinity kept at 400-500 mg/L could meet the requirement of the treating process. The JLAFB reactor had great advantage in avoiding sulfide and free-H2S accumulation and toxicity inhibition on microorganisms. When sulfate loading rate was up to 8. 1 kg/（m^3.d）, the sulfide and free-H2S concentrations in JLAFB reactor were 58.6 and 49.7 mg/L, respectively. Furthermore, the granules, with offwhite color, ellipse shape and diameters of 1.0-3.0 mm, could be developed in JLAFB reactor. In granules, different groups of bacteria were distributed in different layers, and some inorganic metal compounds such as Fe, Ca, Mg etc. were found.

Startup and operation of anaerobic EGSB reactor treating palm oil mill effluent

A bench-scale expanded granular sludge bed （EGSB） reactor was applied to the treatment of palm oil mill effluent （POME）. The reactor had been operated continuously at 35℃ for 514 d, with organic loading rate （OLR） increased from 1.45 to 17.5 kg COD/（m^3·d）. The results showed that the EGSB reactor had good performance in terms of COD removal on the one hand, high COD removal of 91% was obtained at two days＇ of hydraulic retention time （HRT）, and the highest OLR of 17.5 kg COD/（m^3·d）. On the other hand, only 46% COD in raw POME was transformed into biogas in which the methane content was about 70% （V/V）. A 30-d intermittent experiment indicated that the maximum transformation potential of organic matter in raw POME into methane was 56%. Volatile fatty acid （VFA） accumulation was observed in the later operation stage, and this was settled by supplementing trace metal elements. On the whole, the system exhibited good stability in terms of acidity and alkalinity. Finally, the operational problems inherent in the laboratory scale experiment and the corresponding countermeasures were also discussed.

Influence of lactic acid on the two-phase anaerobic digestion of kitchen wastes

To evaluate the influence of lactic acid on the methanogenesis, anaerobic digestion of kitchen wastes was firstly conducted in a two-phase anaerobic digestion process, and performance of two digesters fed with lactic acid and glucose was subsequently compared. The results showed that the lactic acid was the main fermentation products of hydrolysis-acidification stage in the two-phase anaerobic digestion process for kitchen wastes. The lactic acid concentration constituted approximately 50% of the chemical oxygen demand （COD） concentration in the hydrolysis-acidification liquid. The maximum organic loading rate was lower in the digester fed with lactic acid than that fed with glucose. Volatile fatty acids （VFAs） and COD removal were deteriorated in the methanogenic reactor fed with lactic acid compared to that fed with glucose. The specific methanogenic activity （SMA） declined to 0.343 g COD/（gVSS-d） when the COD loading were designated as 18.8 g/（L-d） in the digester fed with lactic acid. The propionic acid accumulation occurred due to the high concentration of lactic acid fed. It could be concluded that avoiding the presence of the lactic acid is necessary in the hydrolysis-acidification process for the improvement of the two-phase anaerobic digestion process of kitchen wastes.

Anaerobic tapered fluidized bed reactor for starch wastewater treatment and modeling using multilayer perceptron neural network

treatability of synthetic sago wastewater was investigated in a laboratory anaerobic tapered fluidized bed reactor （ATFBR） with a mesoporous granular activated carbon （GAC） as a support material. The experimental protocol was defined to examine the effect of the maximum organic loading rate （OLR）, hydraulic retention time （HRT）, the efficiency of the reactor and to report on its steady- state performance. The reactor was subjected to a steady-state operation over a range of OLR up to 85.44 kg COD/（m^3·d）. The COD removal efficiency was found to be 92% in the reactor while the biogas produced in the digester reached 25.38 m^3/（m^3·d） of the reactor. With the increase of OLR from 83.7 kg COD/（m^3·d）, the COD removal efficiency decreased. Also an artificial neural network （ANN） model using multilayer perceptron （MLP） has been developed for a system of two input variable and five output dependent variables. For the training of the input-output data, the experimental values obtained have been used. The output parameters predicted have been found to be much closer to the corresponding experimental ones and the model was validated for 30% of the untrained data. The mean square error （MSE） was found to be only 0.0146.

Performance evaluation of up-flow anaerobic sludge blanket(UASB) reactor for treatment of paper mill wastewater

The present study deals with the performance evaluation of the UASB reactor under varied organic loading rate(OLR) for the treatment of paper mill wastewater. The sludge granulation process started after 120 days from the start-up period. Sludge granules size was found to be 0 8 mm at OLR of 1 72 kgCOD/(m 3·d), which reached maximum size of about 1 0 to 1 2 mm at OLR of 2 1 kgCOD/(m 3·d). At the end of initial OLR of 1 0 kgCOD/(m 3·d) the VSS concentration was 12 86 gVSS/L, which got increased to 38 05 gVSS/L at the end of an OLR 2 1 kgCOD/(m 3·d). Most of the times VFA recorded were well within the limit of VFA reported in anaerobic fermentation process. Many times the pH observed was between 6 5 and 7 8, which is more favorable for any anaerobic process. It is also found that pH within the reactor increases along with the height of reactor. The total maximum biogas production was found to be 0 40 L/gCOD removals at OLR of 2 1 kgCOD/(m 3·d) and the maximum BOD removal at this stage was observed to be 90%.

Influence of temperature on performance of anaerobic digestion of municipal solid waste

The influence of temperature on the performance of anaerobic reactors for treating the organic fraction of municipal sohd waste （OFMSW） was studied. Batch digestion of OFMSW was carded out for 32 d at different temperature （25℃, 35℃, 45℃ and 55℃） conditions for total solid concentrations （TS） 17% with the ratio of total organic carbon to nitrogen （C/N） being, 25：1 respectively, while keeping other parameters constant such as inoculum, start-up pH, reactor volume （2 L） and so on. Temperature can influence the methanogenic bacteria activity, accordingly inhibiting the OFMSW biodegradation and stabilization efficiency. Anaerobic reactors excelled at TS reduction, total volatile solid reduction, chemical oxygen demand reduction, increasing cumulative biogas production, whose rate was at temperature （35℃ and 55℃） conditions. Methane concentration in the biogas was above 65% in four reactors. In addition, the fluctuation of temperatures resulted in the biogas production variation. The data obtained indicated that temperature had a significant influence on anaerobic process.

Effects of Oxytetracycline on Methane Production and the Microbial Communities During Anaerobic Digestion of Cow Manure

The effects of different concentrations of oxytetracycline （OTC） on the dynamics of bacterial and archaeal communities during the mesophilic anaerobic digestion （37＆#176;C） of cow manure were investigated. Before anaerobic digestion, OTC was added to digesters at concentrations of 20, 50, and 80 mg L-1, respectively. Compared with no-antibiotic control, all methane productions underwent different levels of inhibition at different concentrations of OTC. Changes in the bacterial and archaeal communities were discussed by using PCR-denaturing gradient gel electrophoresis （DGGE）. Results showed that OTC affected the richness and diversity of bacterial and archaeal communities. The bacterial genus Flavobacterium and an uncultured bacterium （JN256083.1） were detected throughout the entire process of anaerobic digestion and seemed to be the functional bacteria. Methanobrevibacter boviskoreani and an uncultured archaeon （FJ230982.1） dominated the archaeal communities during anaerobic digestion. These microorganisms may have high resistance to OTC and may play vital roles in methane production.

Combined pretreatment using CaO and liquid fraction of digestate of rice straw: Anaerobic digestion performance and electron transfer

To improve anaerobic digestion(AD)efficiency of rice straw,solid alkaline CaO and the liquid fraction of digestate(LFD)were used as pretreatment agents of rice straw.The results showed that AD performance of rice straw with CaOLFD pretreatment was optimal in different pretreatment methods of the CaO+LFD,CaOLFD,LFD+CaO,CaO,and LFD.The maximum methane yield(314 ml(g VS)^(-1))and the highest VFAs concentration(14851 mg·L^(-1) on day 3)of the CaOLFD pretreatment group were 81%and 118%higher than that of the control group,respectively.Under the action of solid alkaline CaO,the bacteria of Clostridium,Atopostipes,Sphaerochaeta,Tissierella,Thiopseudomonas,Rikenellaceae,and Sedimentibacter could build up co-cultures with the archaeal of Methanosaeta,Methanobacterium,and Methanosarcina performing direct interspecies electron transfer(DIET)and improving AD performance of rice straw.Therefore,the combined pretreatment using CaO and LFD could not only pretreat rice straw but also stimulate co-cultures of microorganism to establish DIET enhancing AD efficiency.

The Role of Biochar to Enhance Anaerobic Digestion: A Review

Biochar,one of the products of thermochemical conversion of biomass,possesses specific physiochemical properties such as conductivity,pore adsorption,surface functional groups,and cation exchange capacity.Anaerobic digestion(AD)as a classical bio-wastes conversion technology,suffers from inhibitions,process instability,and methanogenic inefficiency which limit its efficiency.With the advantages of pH buffering,functional microbes enrichment,inhibitors alleviating,and direct interspecies electron transfer(DIET)accelerating,biochar suggests a promising application as additives for AD.Herein,this paper reviewed the noting physicochemical properties of biochar,and discussed its roles and related mechanisms in AD.Further,this paper highlighted the advantages and drawbacks,and pointed out the corresponding challenges and prospects for future research and application of biochar amending AD.

Effects of Different States of Fe on Anaerobic Digestion:A Review

Anaerobic digestion is widely used in the treatment of industrial wastewater,excess activated sludge,municipal waste,crop straw and livestock manure,with the functions of environmental protection and energy recovery. This review summarizes and evaluates the present knowledge of effects of different states of Fe( ZVI,Fe( II),Fe( III)) on hydrogen and methane production in anaerobic digestion process. The potential promotion effects of iron oxides nanoparticles( IONPs),especially magnetite nanoparticles on anaerobic digestion are also mentioned. Fe plays important role in transporting electron,stimulating bacterial growth and increasing hydrogen and methane production rate by promoting enzyme activity. Adding Fe with different morphologies and valence states in anaerobic digestion to increase biogas( hydrogen and methane) production and enhance organic matter degradation simultaneously,which has attracted many scientists' attention in recent years. Rapid progress in this area has been made over the last few years,since Fe is essential to the fermentative hydrogen and methane production,while few is known about how Fe affects the fermentative biogas production. This review is significant to maintain the stable operation of the biogas project.

Anaerobic digestion for waste water poultry manure by UBF reactor

In this experiment the performance of UBF process treatment for wastewater chicken manure was tested under the condition of constant temperature of 35℃and the volume of UBF is 4 liters.The experiment covered two stages:the first was start up with phase I and phase II,the second was steady state.The following results average of operation period were obtained:(1)During the period of start up phase I operation the biogas production rate 0.39v/(v.day)at the volumetric COD loading rate of 2.97 kg COD/(m 3.d)with COD removal 76.85%and hydraulic retention time of 10.04 hours and phase II the biogas production rate 3.86 v/(v.day)at the volume loading rate 11.69 kg COD/(m 3.d)have been achieved with COD removal 82.47%and HRT 16.45 hours.UBF process had resistance to the quantitative shock load.(2)During the steady state operation,the biogas production rate 9.83v/(v.day)at loading rate of 28.85 kg COD/(m 3.d)and COD removal efficiency 80.03%and hydraulic retention time of 18.73 hours have been achieved for this reactor.The operation of UBF reactor was very stable.

Facultative-anaerobic microbial digestion of coal preparation waste and use of effluent solids to enhance plant growth in a sandy soil

Coal preparation solid waste,which is a major environmental issue for coal-producing areas in China,may be microbiologically digested and transformed into a product suitable as a soil amendment to increase soil organic matter content and prevent and enhance plant/crop growth.Coal preparation waste collected from a coal sorting plant in Inner Mongolia,China was digested in bioreactors inoculated with microbial enrichments prepared from activated sludge and cow manure.The effluent solids from the coal preparation waste bioreactors were analyzed for their suitability as organic soil amendments,which complied with China standards.Plant growth tests were conducted in sandy soil from a semi-arid region in Colorado,which was amended with the effluent solids.Kentucky bluegrass(Poa pratensis L.)and chives(Allium schoenoprasum)were used as the representative plants for the growth tests,where results indicated substantially higher yields of Kentucky bluegrass and chives for the sandy soils amended with the effluent solids when compared to a commercial organic fertilizer.The number and average length of Kentucky bluegrass shoots were 10 and 5.1 times higher,respectively,in soils amended with the effluent solids.Similarly,the number and average length of chives shoots were 10 and 1.7 times higher,respectively,in soils amended with the effluent solids.Overall,the microbial digestion of coal preparation waste for application as an organic soil amendment is a viable alternative and beneficial use of coal preparation solid waste.