Recently microbial fuel cells (MFCs) have been considered as an alternative power generation technique by utilizing organic wastes. In this study, an experiment was carried out to generate bioelectricity from co-diges...Recently microbial fuel cells (MFCs) have been considered as an alternative power generation technique by utilizing organic wastes. In this study, an experiment was carried out to generate bioelectricity from co-digestion of organic waste (kitchen waste) and sewage sludge as a waste management option using microbial fuel cell (MFC) in anaerobic process. A total of five samples with different sludge-waste ratio were used with zinc (Zn) and cupper (Cu) as cell electrodes for the test. The trends of voltage generation were different for each sample in cells such as 350 mV, 263 mV, 416 mV maximum voltage were measured from sample I, II and III respectively. It was observed that the MFC with sewage sludge showed the higher values (around 960 mV) of voltages with time whereas 918 mV obtained with organic waste. Precisely comparing cases with varying the organic waste and sewage sludge ratio helps to find the best bioelectricity generation option. Using MFCs can be appeared as the solution of electricity scarcity along the world as an efficient and eco-friendly manner as well as organic solid waste and sewage sludge management.展开更多
Energy is the pillar of human economic development. Several energy sources, renewable and non-renewable, have been exploited to assure and sustain the need for sustainable development. However, depletion of non-renewa...Energy is the pillar of human economic development. Several energy sources, renewable and non-renewable, have been exploited to assure and sustain the need for sustainable development. However, depletion of non-renewable energy sources forced researchers to search for alternative cost effective and environmental friendly energy sources. Thus, conversion of waste materials into energy has obtained considerable attention. In line with this, the aim of this study is to investigate the improvement of bio-energy production through anaerobic digestion of mixture of wastes from sewage sludge and abattoir sources. The abattoir waste is functioned as a co-substrate. Laboratory scale batch anaerobic co-digestion of the waste is carried out under mesophilic condition for 20 days. Sewage Sludge (SS) alone, and different mix ratios of SS to Abattoir Waste (AW) were analyzed for bioenergy production. Besides, the nutrient values and reduction in volume of the sewage after digestion were determined. The results show that methane productions of 33.8%, 48.3% and 56.9% were obtained for SS alone and for SS:AW mix ratios of 4:1 and 3:2, respectively. The nutrient values of the slurry increased as mix ratio decreased due to the increase in the amount of AW. The obtained results indicate that bio-energy production can be improved through co-digestion of SS using AW as a co-substrate;thus warranting further investigation for the practical application in the energy production.展开更多
Along with the development and progress of environmental protection management,it is necessary to pay full attention to the disposal of excess sludge in the process of urban sewage treatment plant management.It is nec...Along with the development and progress of environmental protection management,it is necessary to pay full attention to the disposal of excess sludge in the process of urban sewage treatment plant management.It is necessary to ensure effective integration of management mechanisms and management paths.To a certain extent,it can improve the actual efficiency of digestion and treatment work and lay a foundation for the optimal operation of environmental protection management.In this paper,the treatment of excess sludge in a sewage treatment plant is studied.The method and results of anaerobic digestion test of excess sludge in a sewage treatment plant are discussed for reference only.展开更多
Previous study found that the pre-treatment of sewage sludge with nitrite improves the biogas production during the mono/two-phase anaerobic digestion (AD) using batch biochemical methane potential tests.In this study...Previous study found that the pre-treatment of sewage sludge with nitrite improves the biogas production during the mono/two-phase anaerobic digestion (AD) using batch biochemical methane potential tests.In this study,the effects of nitrite on hydrolysisacidification,biogas production,volatile solids destruction and microbial composition in semi-continuous two-phase AD of sewage sludge were investigated.The addition of nitrite promotes sludge organic matter solubilization (+484%) and VFAs production (+98.9%),and causes an increase in the VS degradation rate during the AD process (+8.7%).The comparison of biogas production from the acidogenic and methanogenic reactors with or without the addition of nitrite implies that the nitrite has no significant effect on the overall biogas production of two-phase sludge AD process.High-throughput sequencing analysis shows that the microbial communities of bacteria and archaea in two-phase AD reactors significantly changes after the addition of nitrite.Vulcanibacillus (bacteria) and Candidatus Methanofastidiosum (archaea) become the dominant genera in the acidogenic and methanogenic reactors with the nitrite respectively.These findings provide new insights about using nitrite to promote the organic matter degradation of sewage sludge in a semicontinuous two-phase AD system.展开更多
Low organic matter content and high heavy metal levels severely inhibit the anaerobic digestion(AD) of sewage sludge. In this study, the effect of added manganese oxidemodified biochar composite(MBC) on methane produc...Low organic matter content and high heavy metal levels severely inhibit the anaerobic digestion(AD) of sewage sludge. In this study, the effect of added manganese oxidemodified biochar composite(MBC) on methane production and heavy metal fractionation during sewage sludge AD was examined. The MBC could increase the buffering capacity,enhance the methane production and degradation of intermediate acids, buffer the pH of the culture, and stabilize the sewage sludge AD process. The application of MBC positively impacted methane production and the cumulative methane yield increased up to 121.97%,as compared with the control. The MBC addition can improve metal stabilization in the digestate. An optimum MBC dose of 2.36 g was recommended, which would produce up to 121.1 L/kg volatile solids of methane. After the AD process, even though most of the metals accumulated in the residual solids, they could be transformation from the bio-available fractions to a more stable fraction. The total organic-and sulfide-bound and residual fraction content at a 3 g dose of MBC that is 0.12 g/g dry matter were 51.06% and 35.11% higher than the control, respectively. The results indicated that the application of MBC could improve the performance of AD and promote stabilization of heavy metals in sewage sludge post the AD process.展开更多
High-solids anaerobic digestion of sewage sludge was a promising process, but high solid concentra- tion negatively influenced methane production. The influencing mechanism was systematically analyzed in this study th...High-solids anaerobic digestion of sewage sludge was a promising process, but high solid concentra- tion negatively influenced methane production. The influencing mechanism was systematically analyzed in this study through a series of static anaerobic digestion experiments at total solids (TS) contents of 3%--15%. The results showed that TS 6% was the boundary between low- solids and high-solids anaerobic digestion, and the accumulative methane yield decreased exponentially when TS increased from 6% to 15%. The performance of anaerobic digestion was directly determined by the efficiency of mass transfer, and the relation between methane yield and sludge diffusive coefficients was well described by a power function. Thus, the increasing TS resulted in an exponential increase in sludge viscosity but an exponential decrease in diffusive coefficient. The blocked mass transfer led to the accumulation of volatile fatty acids (VFAs) and free ammonia. Acetic metabolism was the main process, whereas butyric and propionic metabolisms occurred at the initial stage of high-solids anaerobic digestion. The concentration of VFAs reached the maximum at the initial stage, which were still lower than the threshold influencing methanogens. The concen- tration of free ammonia increased gradually, and the methanogenesis was inhibited when free ammonia nitro- gen exceeded 50 mg.L^-1. Consequently, the deterioration of high-solids anaerobic digestion was related to the blocked mass transfer and the resulting ammonia accumu- lation.展开更多
Impact of ultrasonication(ULS) and ultrasonication-ozonation(ULS-Ozone) pre-treatment on the anaerobic digestibility of sewage sludge was investigated with semi-continuous anaerobic reactors at solid retention tim...Impact of ultrasonication(ULS) and ultrasonication-ozonation(ULS-Ozone) pre-treatment on the anaerobic digestibility of sewage sludge was investigated with semi-continuous anaerobic reactors at solid retention time(SRT) of 10 and 20 days. The control, ULS and ULS-Ozone reactors produced 256, 309 and 348 m L biogas/g CODfedand the volatile solid(VS) removals were 35.6%, 38.3% and 42.1%, respectively at SRT of 10 days. At SRT of20 days, the biogas yields reached 313, 337 and 393 m L biogas/g CODfedand the VS removal rates were 37.3%, 40.9% and 45.3% in the control, ULS and ULS-Ozone reactors, respectively.ULS-Ozone pre-treatment increased the residual organic amount in the digested sludge.These soluble residual organics were found to contain macromolecules with molecular weights(MW) larger than 500 k Da and smaller polymeric products with MW around 19.4and 7.7 k Da. These compounds were further characterized to be humic acid-like substances with fluorescent spectroscopy analysis.展开更多
Anaerobic digestion (AD) is gaining increasing attention due to the ability to covert organic pollutants into energy-rich biogas and, accordingly, growing interest is paid to the microbial ecology of AD systems. Des...Anaerobic digestion (AD) is gaining increasing attention due to the ability to covert organic pollutants into energy-rich biogas and, accordingly, growing interest is paid to the microbial ecology of AD systems. Despite extensive efforts, AD microbial ecology is still limitedly understood, especially due to the lack of quantitative information on the structures and dynamics of AD microbial communities. Such knowledge gap is particularly pronounced in sewage sludge AD processes although treating sewage sludge is among the major practical applications of AD. Therefore, we examined the microbial communities in three full-scale sewage sludge digesters using qualitative and quantitative molecular techniques in combination: denaturing gradient gel electrophoresis (DGGE) and real-time polymerase chain reaction (PCR). Eight out of eleven bacterial sequences retrieved from the DGGE analysis were not affiliated to any known species while all eleven archaeal sequences were assigned to known methanogen species. Quantitative real-time PCR analysis revealed that, based on the 16S rRNA gene abundance, the hydrogenotrophic order Methanomicrobiales is the most dominant methanogen group (〉 94% of the total methanogen population) in all digesters. This corresponds well to the prevailing occurrence of the DGGE bands related to Methanolinea and Methanospirillum, both belonging to the order Methanomicrobiales, in all sludge samples. It is therefore suggested that hydrogenotrophic methanogens, especially Methanomicrobiales strains, are likely the major players responsible for biogas production in the digesters studied. Our observation is contrary to the conventional understanding that aceticlastic methanogens generally dominate methanogen communities in stable AD environments, suggesting the need for further studies on the dominance relationship in various AD systems.展开更多
In recent years,volatile fatty acid(VFA)production through anaerobic fermentation of sewage sludge,instead of methane production,has been regarded as a high-value and promising roadmap for sludge stabilization and res...In recent years,volatile fatty acid(VFA)production through anaerobic fermentation of sewage sludge,instead of methane production,has been regarded as a high-value and promising roadmap for sludge stabilization and resource recovery.This review first presents the effects of some essential factors that influence VFA production and composition.In the second part,we present an extensive analysis of conventional pretreatment and co-fermentation strategies ultimately addressed to improving VFA production and composition.Also,the effectiveness of these approaches is summarized in terms of sludge degradation,hydrolysis rate,and VFA production and composition.According to published studies,it is concluded that some pretreatments such as alkaline and thermal pretreatment are the most effective ways to enhance VFA production from sewage sludge.The possible reasons for the improvement of VFA production by different methods are also discussed.Finally,this review also highlights several current technical challenges and opportunities in VFA production with spectrum control,and further related research is proposed.展开更多
The pyrolysis properties of five different pyrolysis tars, which the tars from 1# to 5# are obtained by pyrolyzing the sewage sludges of anaerobic digestion and indigestion from the A2/O wastewater treatment process, ...The pyrolysis properties of five different pyrolysis tars, which the tars from 1# to 5# are obtained by pyrolyzing the sewage sludges of anaerobic digestion and indigestion from the A2/O wastewater treatment process, those from the activated sludge process and the indigested sludge from the continuous SBR process respectively, were studied by thermal gravimetric analysis at a heating rate of 10 ℃/min in the nitrogen atmosphere. The results show that the pyrolysis processes of the pyrolysis tars of 1#, 2#, 3# and 5# all can be divided into four stages: the stages of light organic compounds releasing, heavy polar organic compounds decomposition, heavy organic compounds decomposition and the residual organic compounds decomposition. However, the process of 4# pyrolysis tar is only divided into three stages: the stages of light organic compounds releasing, decomposition of heavy polar organic compounds and the residual heavy organic compounds respectively. Both the sludge anaerobic digestion and the "anaerobic" process in wastewater treatment processes make the content of light organic compounds in tars decrease, but make that of heavy organic compounds with complex structure increase. Besides, both make the pyrolysis properties of the tars become worse. The pyrolysis reaction mechanisms of the five pyrolysis tars have been studied with Coats-Redfern equation. It shows that there are the same mechanism functions in the first stage for the five tars and in the second and third stage for the tars of 1#, 2#, 3# and 5#, which is different with the function in the second stage for 4# tar. The five tars are easy to volatile.展开更多
文摘Recently microbial fuel cells (MFCs) have been considered as an alternative power generation technique by utilizing organic wastes. In this study, an experiment was carried out to generate bioelectricity from co-digestion of organic waste (kitchen waste) and sewage sludge as a waste management option using microbial fuel cell (MFC) in anaerobic process. A total of five samples with different sludge-waste ratio were used with zinc (Zn) and cupper (Cu) as cell electrodes for the test. The trends of voltage generation were different for each sample in cells such as 350 mV, 263 mV, 416 mV maximum voltage were measured from sample I, II and III respectively. It was observed that the MFC with sewage sludge showed the higher values (around 960 mV) of voltages with time whereas 918 mV obtained with organic waste. Precisely comparing cases with varying the organic waste and sewage sludge ratio helps to find the best bioelectricity generation option. Using MFCs can be appeared as the solution of electricity scarcity along the world as an efficient and eco-friendly manner as well as organic solid waste and sewage sludge management.
文摘Energy is the pillar of human economic development. Several energy sources, renewable and non-renewable, have been exploited to assure and sustain the need for sustainable development. However, depletion of non-renewable energy sources forced researchers to search for alternative cost effective and environmental friendly energy sources. Thus, conversion of waste materials into energy has obtained considerable attention. In line with this, the aim of this study is to investigate the improvement of bio-energy production through anaerobic digestion of mixture of wastes from sewage sludge and abattoir sources. The abattoir waste is functioned as a co-substrate. Laboratory scale batch anaerobic co-digestion of the waste is carried out under mesophilic condition for 20 days. Sewage Sludge (SS) alone, and different mix ratios of SS to Abattoir Waste (AW) were analyzed for bioenergy production. Besides, the nutrient values and reduction in volume of the sewage after digestion were determined. The results show that methane productions of 33.8%, 48.3% and 56.9% were obtained for SS alone and for SS:AW mix ratios of 4:1 and 3:2, respectively. The nutrient values of the slurry increased as mix ratio decreased due to the increase in the amount of AW. The obtained results indicate that bio-energy production can be improved through co-digestion of SS using AW as a co-substrate;thus warranting further investigation for the practical application in the energy production.
文摘Along with the development and progress of environmental protection management,it is necessary to pay full attention to the disposal of excess sludge in the process of urban sewage treatment plant management.It is necessary to ensure effective integration of management mechanisms and management paths.To a certain extent,it can improve the actual efficiency of digestion and treatment work and lay a foundation for the optimal operation of environmental protection management.In this paper,the treatment of excess sludge in a sewage treatment plant is studied.The method and results of anaerobic digestion test of excess sludge in a sewage treatment plant are discussed for reference only.
基金supported by the China Three Gorges Group Co.LTD (No.202003080)the National Key Research and Development Project (Nos.2020YFC1908702,2021YFC_(3)200704)。
文摘Previous study found that the pre-treatment of sewage sludge with nitrite improves the biogas production during the mono/two-phase anaerobic digestion (AD) using batch biochemical methane potential tests.In this study,the effects of nitrite on hydrolysisacidification,biogas production,volatile solids destruction and microbial composition in semi-continuous two-phase AD of sewage sludge were investigated.The addition of nitrite promotes sludge organic matter solubilization (+484%) and VFAs production (+98.9%),and causes an increase in the VS degradation rate during the AD process (+8.7%).The comparison of biogas production from the acidogenic and methanogenic reactors with or without the addition of nitrite implies that the nitrite has no significant effect on the overall biogas production of two-phase sludge AD process.High-throughput sequencing analysis shows that the microbial communities of bacteria and archaea in two-phase AD reactors significantly changes after the addition of nitrite.Vulcanibacillus (bacteria) and Candidatus Methanofastidiosum (archaea) become the dominant genera in the acidogenic and methanogenic reactors with the nitrite respectively.These findings provide new insights about using nitrite to promote the organic matter degradation of sewage sludge in a semicontinuous two-phase AD system.
基金supported by the Foundation of National Special Item on Water Resource and Environment (No.2014ZX07303003 and 2017ZX07603003)
文摘Low organic matter content and high heavy metal levels severely inhibit the anaerobic digestion(AD) of sewage sludge. In this study, the effect of added manganese oxidemodified biochar composite(MBC) on methane production and heavy metal fractionation during sewage sludge AD was examined. The MBC could increase the buffering capacity,enhance the methane production and degradation of intermediate acids, buffer the pH of the culture, and stabilize the sewage sludge AD process. The application of MBC positively impacted methane production and the cumulative methane yield increased up to 121.97%,as compared with the control. The MBC addition can improve metal stabilization in the digestate. An optimum MBC dose of 2.36 g was recommended, which would produce up to 121.1 L/kg volatile solids of methane. After the AD process, even though most of the metals accumulated in the residual solids, they could be transformation from the bio-available fractions to a more stable fraction. The total organic-and sulfide-bound and residual fraction content at a 3 g dose of MBC that is 0.12 g/g dry matter were 51.06% and 35.11% higher than the control, respectively. The results indicated that the application of MBC could improve the performance of AD and promote stabilization of heavy metals in sewage sludge post the AD process.
文摘High-solids anaerobic digestion of sewage sludge was a promising process, but high solid concentra- tion negatively influenced methane production. The influencing mechanism was systematically analyzed in this study through a series of static anaerobic digestion experiments at total solids (TS) contents of 3%--15%. The results showed that TS 6% was the boundary between low- solids and high-solids anaerobic digestion, and the accumulative methane yield decreased exponentially when TS increased from 6% to 15%. The performance of anaerobic digestion was directly determined by the efficiency of mass transfer, and the relation between methane yield and sludge diffusive coefficients was well described by a power function. Thus, the increasing TS resulted in an exponential increase in sludge viscosity but an exponential decrease in diffusive coefficient. The blocked mass transfer led to the accumulation of volatile fatty acids (VFAs) and free ammonia. Acetic metabolism was the main process, whereas butyric and propionic metabolisms occurred at the initial stage of high-solids anaerobic digestion. The concentration of VFAs reached the maximum at the initial stage, which were still lower than the threshold influencing methanogens. The concen- tration of free ammonia increased gradually, and the methanogenesis was inhibited when free ammonia nitro- gen exceeded 50 mg.L^-1. Consequently, the deterioration of high-solids anaerobic digestion was related to the blocked mass transfer and the resulting ammonia accumu- lation.
文摘Impact of ultrasonication(ULS) and ultrasonication-ozonation(ULS-Ozone) pre-treatment on the anaerobic digestibility of sewage sludge was investigated with semi-continuous anaerobic reactors at solid retention time(SRT) of 10 and 20 days. The control, ULS and ULS-Ozone reactors produced 256, 309 and 348 m L biogas/g CODfedand the volatile solid(VS) removals were 35.6%, 38.3% and 42.1%, respectively at SRT of 10 days. At SRT of20 days, the biogas yields reached 313, 337 and 393 m L biogas/g CODfedand the VS removal rates were 37.3%, 40.9% and 45.3% in the control, ULS and ULS-Ozone reactors, respectively.ULS-Ozone pre-treatment increased the residual organic amount in the digested sludge.These soluble residual organics were found to contain macromolecules with molecular weights(MW) larger than 500 k Da and smaller polymeric products with MW around 19.4and 7.7 k Da. These compounds were further characterized to be humic acid-like substances with fluorescent spectroscopy analysis.
基金supported by the 2013 Research Fund of Ulsan National Institute of Science and Technology through a Future Challenge Project
文摘Anaerobic digestion (AD) is gaining increasing attention due to the ability to covert organic pollutants into energy-rich biogas and, accordingly, growing interest is paid to the microbial ecology of AD systems. Despite extensive efforts, AD microbial ecology is still limitedly understood, especially due to the lack of quantitative information on the structures and dynamics of AD microbial communities. Such knowledge gap is particularly pronounced in sewage sludge AD processes although treating sewage sludge is among the major practical applications of AD. Therefore, we examined the microbial communities in three full-scale sewage sludge digesters using qualitative and quantitative molecular techniques in combination: denaturing gradient gel electrophoresis (DGGE) and real-time polymerase chain reaction (PCR). Eight out of eleven bacterial sequences retrieved from the DGGE analysis were not affiliated to any known species while all eleven archaeal sequences were assigned to known methanogen species. Quantitative real-time PCR analysis revealed that, based on the 16S rRNA gene abundance, the hydrogenotrophic order Methanomicrobiales is the most dominant methanogen group (〉 94% of the total methanogen population) in all digesters. This corresponds well to the prevailing occurrence of the DGGE bands related to Methanolinea and Methanospirillum, both belonging to the order Methanomicrobiales, in all sludge samples. It is therefore suggested that hydrogenotrophic methanogens, especially Methanomicrobiales strains, are likely the major players responsible for biogas production in the digesters studied. Our observation is contrary to the conventional understanding that aceticlastic methanogens generally dominate methanogen communities in stable AD environments, suggesting the need for further studies on the dominance relationship in various AD systems.
基金supported by the National Natural Science Foundation of China(No.51578068)"One Thousand Talent Plan" Youth Program
文摘In recent years,volatile fatty acid(VFA)production through anaerobic fermentation of sewage sludge,instead of methane production,has been regarded as a high-value and promising roadmap for sludge stabilization and resource recovery.This review first presents the effects of some essential factors that influence VFA production and composition.In the second part,we present an extensive analysis of conventional pretreatment and co-fermentation strategies ultimately addressed to improving VFA production and composition.Also,the effectiveness of these approaches is summarized in terms of sludge degradation,hydrolysis rate,and VFA production and composition.According to published studies,it is concluded that some pretreatments such as alkaline and thermal pretreatment are the most effective ways to enhance VFA production from sewage sludge.The possible reasons for the improvement of VFA production by different methods are also discussed.Finally,this review also highlights several current technical challenges and opportunities in VFA production with spectrum control,and further related research is proposed.
基金supported by the project of Tianjin higher education under contract (20060522)the project of Tianjin Polytechnic University (2230004)
文摘The pyrolysis properties of five different pyrolysis tars, which the tars from 1# to 5# are obtained by pyrolyzing the sewage sludges of anaerobic digestion and indigestion from the A2/O wastewater treatment process, those from the activated sludge process and the indigested sludge from the continuous SBR process respectively, were studied by thermal gravimetric analysis at a heating rate of 10 ℃/min in the nitrogen atmosphere. The results show that the pyrolysis processes of the pyrolysis tars of 1#, 2#, 3# and 5# all can be divided into four stages: the stages of light organic compounds releasing, heavy polar organic compounds decomposition, heavy organic compounds decomposition and the residual organic compounds decomposition. However, the process of 4# pyrolysis tar is only divided into three stages: the stages of light organic compounds releasing, decomposition of heavy polar organic compounds and the residual heavy organic compounds respectively. Both the sludge anaerobic digestion and the "anaerobic" process in wastewater treatment processes make the content of light organic compounds in tars decrease, but make that of heavy organic compounds with complex structure increase. Besides, both make the pyrolysis properties of the tars become worse. The pyrolysis reaction mechanisms of the five pyrolysis tars have been studied with Coats-Redfern equation. It shows that there are the same mechanism functions in the first stage for the five tars and in the second and third stage for the tars of 1#, 2#, 3# and 5#, which is different with the function in the second stage for 4# tar. The five tars are easy to volatile.