Weak Expansive Soil Physical Properties Modification by Means of a Cement-Jute Fiber

Sixteen groups of comprehensive tests have been conducted to investigate the modifications in the physical properties of a weak expansive soil due to the addition of a cement jute fiber.The tests have been conducted to analyze the liquid plastic limit,the particle distribution and the free expansion rate.The results show that:(1)With an increase in the cement-jute fiber content,the free expansion rate of the modified expansive soil gradually decreases,however,such a rate rebounds when the fiber content exceeds 0.5%and the cement content exceeds 6%.(2)With an increase in the cement percentage,the particle unevenness coefficient(Cu)and curvature coefficient(Cc)of the modified expansive soil tend to grow gradually.The Cc coefficient reaches 1.0 when the cement content is 6%.The unevenness coefficient of 16 soil samples is greater than 5.0,however,the Cu coefficient decreases when the cement content reaches 6%.(3)The plastic limit of soil increases as the cement content is made higher,while the liquid limit and plastic index decrease gradually.When the content of the modified material is 2%+0.1%~2%+0.7%(Cement content+jute fiber content),the change of particle size distribution is most obvious.(4)When the contents of cement and jute fiber are is 6%and 0.5%,respectively,the modification induced in the physical properties of soil samples corresponds to the best case.

水泥-微硅粉改良膨胀土工程特性试验研究

为研究水泥和微硅粉复合改良膨胀土作为路基填筑材料的工程性质,以南阳市内乡县某路段膨胀土路基填料为研究对象,通过膨胀力试验、无荷膨胀率试验、无侧限抗压强度试验以及直剪试验,分析其在不同养护龄期下的膨胀特性和力学特性,结合SEM电镜扫描分析改良机理,并探讨了改良膨胀土力学特性变化与微观形貌之间的关系。结果表明:随着水泥、微硅粉的加入及养护龄期的增加,改良膨胀土的抗压强度及抗剪强度提高,膨胀性降低;采用水泥-微硅粉复合改良膨胀土的效果更优;综合考虑改良效果和经济性,改良剂的最优掺量为水泥7%、微硅粉10%。

Laboratory Test on Long-Term Deterioration of Cement Soil in Seawater Environment

Laboratory tests were conducted to study the effects of curing time, cement ratio and seawater pressure on cement soil deterioration formed at simulative marine soft clay sites. Deterioration depth was determined on the basis of characteristics of penetration resistance and penetration depth curves, and the deterioration depth of cement soil with the cement ratio of 7%, reached 31.8 mm after 720 d. Results of research indicated that deterioration extended quickly under seawater environment and the deterioration depth increased with the prolonging curing time. In addition, the water pressure could speed up deterioration. With the increase of cement content, the strength of cement soil increased obviously. At the same time, the deterioration depth decreased significantly. The concentration of calcium ion in the cement stabilized soil increased with the increase of depth, while that of magnesium ion gradually decreased. The variations were consistent with energy dispersive spectrometer(EDS)analysis results, and the calcium concentration with depth was in a good consistency with strength distribution at long term. The results showed that the deterioration became more serious with the curing time, and it was related to calcium leaching.

Simplified method for predicating consolidation settlement of soft ground improved by floating soil-cement column

A simplified method is presented for predicting consolidation settlement of soft ground improved by floating soil-cement column on the basis of double soil-layer consolidation theory. Combining the axisymmetric consolidation model and equal strain assumption, the governing equation was derived for the consolidation of clayey subsoil reinforced by soil-cement column. By modifying the boundary condition of the interface between the improved layer and underlying layer on seepage and pore-water pressure, the analytical solution of consolidation of soft ground improved by floating soil-cement column was developed under depth-dependent ramp load. The results of the parameter analysis of consolidation behavior show that the consolidation rate is closely related with the depth replacement ratio by the column and the permeability of upper layer. The influence of column-soil constrained modulus ratio and radius ratio of the influence zone to the column on consolidation is also affected by depth replacement ratio. The column-soil total stress ratio increases with time and approaches the final value accompanied with the dissipation of excess pore water pressure.

Soil-cement mixture properties and design considerations for reinforced excavation

soil-cement is a mixture produced by grouting or mixing cement with soils. This paper reviews and discusses the general classifications of grouting techniques and the suitability of their applications.The mechanical properties of soil-cement mixture and the influence of sodium silicate added are discussed. Design considerations for deep soil mixed wall(DSMW) for excavation support and vault arch for tunnelling stabilisation are presented. Parameters for the numerical analysis of soil-cement mixture are evaluated and recommended.

砂浆胶-水泥改良膨胀土试验研究

为改良宿迁至连云港段航道膨胀土,选取地表以下0.5~2 m的中等膨胀土,在土中掺入不同比例高分子化合物砂浆胶和水泥混合物,通过直剪试验、膨胀率试验、干湿循环试验和裂隙分析,研究改良后膨胀土的物理力学性质。试验结果表明,随着砂浆胶和水泥的掺入和养护天数增加,膨胀土黏聚力和内摩擦角明显增加,膨胀率减小。改良后的膨胀土裂隙明显减小,且不会随干湿循环次数增加而产生更多裂隙,因此改良后膨胀土强度明显提高、胀缩性明显降低。砂浆胶和水泥改良膨胀土效果显著,成本低,优于其他改良方法,可满足工程需求。

Site observations of weathered granitic soils subjected to cementation and partial drainage using SCPTU

Because of the cementation inherited from the parent rock,weathered granitic soil is usually susceptible to disturbance,which poses considerable challenges for laboratory characterization.The cone penetration test with pore pressure measurements has long been known for its reliability in site investigations and stratigraphic profiling.However,although extensive piezocone test results and experience are available for sedimentary soil,similar advances are yet to be made for weathered granitic soil.Moreover,the experience from sedimentary soil may not be directly applicable to weathered profiles because of the essentially different natures of the two types of geomaterials.This study performs seismic piezocone tests in a weathered granitic profile comprising residual granitic soil,completely weathered granite,and highly weathered granite.Pore pressure is measured at both the cone mid-face and the shoulder,and the effects of penetrometer size and penetration rate are considered.A series of updated soil behavior type charts is proposed to interpret the test results,thereby allowing the effect of weathering to be evaluated.This paper offers an important extension to the sparse data on the in situ responses of weathered materials.

Expansive Soil Stabilization by Bagasse Ash in Partial Replacement of Cement

This study examined the effects of using bagasse ash in replacement of ordinary Portland cement(OPC)in the treatment of expansive soils.The study concentrated on the compaction characteristics,volume change,compressive strength,splitting tensile strength,microstructure,California bearing ratio(CBR)value,and shear wave velocity of expansive soils treated with cement.Different bagasse ash replacement ratios were used to create soil samples.At varying curing times of 7,14,and 28 days,standard compaction tests,unconfined compressive strength tests,CBR tests,Brazilian split tensile testing,and bender element(BE)tests were carried out.According to X-ray diffraction(XRD)investigations,quartz and crystobalite make up the majority of the minerals in bagasse ash.Bagasse ash contains a variety of grain sizes,including numerous fiber-shaped particles,according to a scanning electronic microscope(SEM)test.For all of the treated specimens with various replacement ratios,the overall additive content has not changed.The results of the Brazilian split tensile tests demonstrate improved tensile strength for all specimens with various replacement proportions.A lower maximum dry density and a greater optimal water content would result from the substitution of bagasse ash.When the replacement ratio is not more than 20%,the CBR values of the parts replaced specimens are even higher than the cement treatments.The results of BE testing on the treated soils show that there is significant stiffness anisotropy but that it steadily diminishes with curing time and replacement ratio.According to the study,bagasse ash is a useful mineral additive,and the best replacement ratio(CBA20)is 20%.

Characterization of frozen soil-cement mixture for berm construction in cold regions

Lagoon berms in western Alaska are difficult to design and build due to limited resources, high cost of construction and materials, and warm permafrost conditions. This paper explores methods to treat locally available frozen materials and use them for berm construction. The goal is to find an optimized mix ratio for cement and additives that can be effective in increasing the strength and decreasing the thaw settlement of an ice-rich frozen silty soil. Soil of similar type and ice content to the permafrost found at a project site in Eek, Alaska is prepared in a cold room. The frozen soil is pulverized and cement, additives and fibers are added to the samples for enhancing shear strength and controlling thaw settlement. Thaw settlement and direct shear tests are performed to assess strength and settlement characteristics. This paper presents a sample preparation method, data from thaw settlement and direct shear tests, and analyses of the test results and preliminary conclusions.

Effect of soaking time of dithionite-citrate-bicarbonate solution on strength and deformation characteristics of lateritic soil

This study aimed to reveal the influence of different free-iron-oxides contents on the strength and deformation characteristics of in situ lateritic soil.A test method that combined the selective chemical dissolution method and in situ Ménard pressuremeter test(PMT)was proposed.The soaking time in dithioniteecitrateebicarbonate(DCB)solution was used as a variable to control the free-iron-oxides content in lateritic soil.Then,the in situ lateritic soil boreholes with different soaking time were tested by PMT.The results showed that the in situ horizontal pressure p0,critical edge pressure pf,ultimate pressure prediction pl,pressuremeter modulus Em,shear modulus Gm,and foundation-bearing capacity f0k of lateritic soil decreased rapidly after immersing in DCB solution within 1e4 d.With increasing soaking time,the decrease rate reduced gradually.Moreover,the relationship curve between free-iron-oxides content and soaking time declined rapidly and then stabilized,and the free-iron-oxides content at the inflection point was 30.11 g/kg.When the free-iron-oxides content changed to the inflection point,the free-iron-oxides that played a cementing role was largely removed,indicating that the effective cementing iron-content of Miaoling lateritic soil was about 52.9%.This study demonstrated that the proposed test method can determine the influence of free-iron-oxides content on the strength and deformation characteristics of lateritic soil.

Experimental Study of Dynamic Characteristics on Composite Foundation with CFG Long Pile and Rammed Cement-Soil Short Pile

Based on the idea of optimization design of pile type, the two kinds of the typical pile type are selected, which containing flexibility pile (e.g. rammed cement-soil pile is for short RCSP), and rigid pile (e.g. cement-flyash-gravel pile is for short CFGP). The three kinds of the composite foundation are designed, which are CFGP, CFG long pile and CFG short pile (for short CFGLP-CFGSP), CFG long-short pile and rammed cement-soil short pile (for short CFGLP-RCSSP). Natural earthquake is simulated by using the engineering blasting;the dynamic characteristics and dynamic response of the composite foundation are studied through field test. CFGLP-RCSSP is closed to linear relation. The bearing capacity of the four composite foundation of the CFGP, CFGLP-CFGSP, and CFGLP-RCSSP in the site are 225 kPa, 179 kPa, and 197 kPa, separately increases 150%, 98.8% and 119% compared to the natural foundation. The vibration main frequency is mainly depended on properties of foundation soil and piles between vibration source and measuring point, pilling load value. Horizontal vibration main frequency greater than the vertical vibration main frequency and the vertical vibration main frequency close to the first-order natural frequency of composite foundation. With the pilling load increasing, the CFGLP-RCSSP pile composite foundation combined frequency decreased. Under the same blast energy, the acceleration peak on the CFG pile composite foundation is less than CFGLP-CFGSP the corresponding values, as the load increases, the peak acceleration gently. CFG pile composite foundation is favorable on seismic. The distribution of peak acceleration is consistent within 4 m from pile top in the CFGLP_RCSSP composite foundation. The maximum of the horizontal acceleration peak along the pile body occurs at a distance of pile top 4 m or the pile top, and that of vertical acceleration peak occurred at a pile top.

Assessment of strength development in cement-admixed artificial organic soil with GX07

To explore the stabilization effect of stabilizing agent GX07 on treating organic soil and the influence of organic matter on the strength development of stabilized soil,artificial organic soil with various organic matter content was obtained by adding different amounts of fulvic acid into non-organic clay,and then liquid-plastic limit tests were carried out on the artificial organic soil.Meanwhile,unconfined compressive strength(UCS) tests were performed on cement-only soil and composite stabilized soil,respectively.The test results indicate that the plastic limit of soil samples increases linearly,and the liquid limit increases exponentially as the organic matter content increases.The strength of stabilized soil is well correlated with the organic matter content,cement content,stabilizing agent content and curing time.When the organic matter content is 6%,as the cement content varies in the range of 10%-20%,the strength of cement-only soil increases from 88.5 to 280.8 kPa.Once 12.6% GX07 is added into the mix,the strength of stabilized soil is 4.93 times compared with that of cement-only soil.GX07 can obviously improve the strength of cemented-soil and has a good economic applicability.A strength model is proposed to predict strength development.

Study on influence factors of cement-stabilized soil compressive strength

The cement dry jet mixing method has been used to reinforce soft cohesive ground to increase the strength of soft cohesive ground and to decrease its deformation. The study briefly introduces the curing mechanism of cement-soil,presents the factors of influencing on compressive strength,mainly analyses the factors including cement mixing ratio,cement strength grade,curing age,moisture content and soil texture and puts forward some rational proposals at last.

Experimental Study on Cemented Soil in Sulfate Radical Corrosive solution

The cemented soil is a widely used method to stabilize the weak soil.It would be working in polluted environment,and be influenced by environmental pollution such as acid rain,seawater invasion or industrial pollution,which may lead to deterioration of the structure.In order to simulate and study the erosion effect process including as the changes of corrosive degree of surface,compression strength of cemented soil samples and SO_(4)^(2-)concentration of corrosive solutions,a series of tests are conducted on the cemented soil blocks cured in different concentrations of MgSO_(4),H_(2)SO_(4)and Na_(2)SO_(4)solutions.The test results show that the corrosive degree of the sample surface increases while the compression strength decreases with the increase of the corrosive solution concentration at the same erosion time,and that the corrosive degree increases with the corrosive time.The influence of inorganic compound solutions on the cemented soil follows the order of Na_(2)SO_(4)>MgSO_(4)>H_(2)SO_(4).By analyzing the mechanism,the corrosive type of H_(2)SO_(4)and MgSO_(4)solutions to cemented soil is a composite type of resolving and crystallizing combination,and Na_(2)SO_(4)solution to cemented soil is a composite type of dissolving and crystallizing combination.

Calcium carbonate promotes the formation and stability of soil macroaggregates in mining areas of China

We studied changes in the concentrations of aggregate-cementing agents after different reclamation times and with different fertilization regimes,as well as the formation mechanism of aggregates in reclaimed soil,to provide a theoretical basis for rapid reclamation of soil fertility in the subsidence area of coal mines in Shanxi Province,China.In this study,soil samples of 0–20 cm depth were collected from four fertilization treatments of a longterm experiment started in 2008:no fertilizer (CK),inorganic fertilizer (NPK),chicken manure compost (M),and50%inorganic fertilizer plus 50%chicken manure compost (MNPK).The concentrations of cementing agents and changes in soil aggregate size distribution and stability were analysed.The results showed that the formation of>2 mm aggregates,the aggregate mean weight diameter (MWD),and the proportion of>0.25 mm water-stable aggregates (WR_(0.25)) increased significantly after 6 and 11 years of reclamation.The concentration of organic cementing agents tended to increase with reclamation time,whereas free iron oxide (Fed) and free aluminium oxide(Ald) concentrations initially increased but then decreased.In general,the MNPK treatment signi?cantly increased the concentrations of organic cementing agents and CaCO_(3),and CaCO_(3) increased by 60.4%at 11 years after reclamation.Additionally,CaCO_(3) had the greatest effect on the stability of aggregates,promoting the formation of>0.25 mm aggregates and accounting for 54.4%of the variance in the proportion and stability of the aggregates.It was concluded that long-term reclamation is bene?cial for improving soil structure.The MNPK treatment was the most effective measure for increasing maize grain yield and concentration of organic cementing agents and CaCO_(3).

The Stabilizing Granular Soil with Slow-setting and Slight-expansive Cement

According to the characteristics of granular soil,the technological requirements of the special-purpose cement for stabilizing granular soil are put forward to meet the demands of implementation of highway base engineering.A kind of slow-setting and slight-expansive cement is developed by the cross experiment method in slag-clinker-gypsum-alkaline system,the final setting time of the cement can be prolonged to 8h,and it has properties of low dry shrinkage,high flexural strength and good crack resistance.The strength of granular soil stabilized by the cement is increased by 20% compared with that stabilized by Chinese 425-Grade slag cement.

Numerical computation of anti-liquefaction effect of lattice-type cement-mixed soil countermeasure

Continuous soil-cement wall confinement method to resist liquefaction is a new kind of process. However, whether it also has a good effect on anti-liquefaction or not needs to be urgently answered for earthquake engineering. Quiet boundary is adopted on the lateral face while free field boundary is employed at the bottom. Byrne model on dynamic pore water pressure generation is accepted and natural seismic wave EI Centro whose peak acceleration is adjusted to 0.2 g in proportion is used for input. A double-layer foundation with sandy soil in the upper portion while clay soil in the lower part is chosen as the calculation model, which is 30 m in length and 20 m in width. The groundwater level is on the ground surface. Excess pore water pressure rate is considered as a liquefaction index in the three-dimensional non-linear earthquake response computation. The anti-liquefaction effectiveness and its influencing factors, such as confinement element area are studied. For the natural double-layer foundation, it is liquefied when the excess pore water pressure rate reaches 1.0 under the seismic load. Under the same earthquake load, the peak excess pore water pressure reduces to 0.56 after adopting reinforcement of the continuous soil-cement wall, which is 46% lower than before. It indicates that continuous soil-cement wall confinement method can attain the purpose of anti-liquefaction. Accordingly, it can be a sort of engineering measure to carry on the anti-liquefaction foundation treatment.

The Contribution of the GIS and the Principal Component Analysis in the Study of the Cement’s Dusts Impact on the Top Soils in the Central Part of the Oujda-Taourirt Corridor (Eastern Morocco)

Cement dust pollution is one of the sources of atmospheric pollution. The main impacts of the cement activity to the environment are the broadcasts of dusts and gases. The objective of this study is to determine the effects of cement dust pollution on physico-chemical characteristics of the soil at the vicinity of the cement factory in Oujda-Taourirt corridor (Eastern Morocco) using Principal component analysis (PCA) and geographical information system (GIS). Forty one (41) surface soils (0 - 3 cm) were collected from the six rural townships surrounding the cement factory. The collected soil samples were analyzed for their chemical properties (CaO, Al2O3, Fe2O3, K2O, MgO, SO3 and SiO2) as well as their pH and Electric Conductivity. The results of the analysis showed that the dusts emitted by the cement plant are especially basic and contain a high free lime (43.03% CaO). The principal component analysis applied on the 41 superficial soil samples, allows deducting that the free lime and the sulfur oxide are the tracer elements of this form of pollution. Furthermore, the spatial projection of the factor scores of the principal component analysis using the geographical information system permits us to determine the spatial distribution of more polluted areas of soils as well as to estimate their impact at a zone of 2.5 km of beam around the factory.

Experimental study on interaction mechanism of small H-beams and a soil-cement retaining wall

Small H-beams such as the No.14–20 I-steel can be inserted into soil-cement retaining walls to form small H-beam soil-cement compound walls, functioning both as a retaining wall and a cutoff wall for braced structure excavations. Being different from the mixed soil-cement wall (SMW), the interaction between soil-cement and small H-steel is very good. We have carried out a series of bending experiments on small H-beams in soil-cement model compound beams to study the mechanism of interactions. The results show that the interaction between H-beams and soil-cement is very good, whether the H-beam is single or double. Joint forms of double H-beams at one end have little effect on both the contribution coefficient and on ultimate deflection before cracking. But after cracking, the joint forms greatly affect the contribution coefficient. We conclude that the rigid joint girder for double H-beams is a better choice in practice.

Study of elastic-plastic damage model of cement consolidated soil with high organic content

On the basis of elastic-plastic damage model of cement consolidated soil,the authors took organic contents into reasonable damage variable evolution equation in order to seek relation between the organic contents and parameters in the equation,and established the elastic-plastic damage model of cement consolidated soil considering organic contents.The results show that the parameters change correspondingly with difference of the organic contents.The higher the organic contents are,the less the valves of the parameters such as elastic modulus(E),material parameters(K,n) and damage evolution parameter(ε) become,but the larger strain damage threshold value(εd) of the sample is.Meanwhile,the calculation results obtained from established model are compared with the test data in the condition of common indoors test,which is testified with reliability.