Overview coking plant & Lurgi gasifier plant waste water treatment

The paper described the coking plant and Lurgi gasifier plant waste water types and characteristics , comparing the COD and ammonia-N level in different source of waste water in the plant.The currently maturity coking plant waste water treatment method was statement in the paper and analyzed the pros and cons of each method.The primary cost analysis of each type of waste water treatment was also completed in the paper.According to these analyses , recommendation was prepared for coking plant and Lurgi gasifier plant waste water treatment.

Treatment of coke plant wastewater by SND fixed biofilm hybrid system

In this article, coke plant wastewater was treated by a simultaneous nitrifying and denitrifying （SND） fixed biofilm hybrid system. The results showed that suitable parameters of the system were important for the performance of the bio-degradation system. The chemical oxygen demand （COD） removal efficiency in this system was satisfactory, higher than 94%, and ammonia nitrogen was higher than 95%. The effluent COD concentration could meet the discharge standard, except for very few situations. The results showed that a sufficient carbon source was important for making ammonia nitrogen concentration meet the discharge standard. Then the TiN removal efficiency in this system can be brought higher than 94%. Dissolved oxygen （DO） is very important to the performance of the SND bio-degradation system, and the suitable DO is about 3.5-4.0 mg/L at the forepart of reactor. In addition, the performance of the system was almost not affected by pH value. The results show that the system is feasible to treat coke plant wastewater.

Decomposition of Organic Compounds in Coke Plant Wastewater by Ultrasonic Irradiation and Its Combined Process

The paper deals with the degradation of the organic compounds in the coke plant wastewater by the combined process of ultrasonic irradiation and activated sludge. The influence factors of the ultrasonic degradation effect such as air atmosphere, initial concentration, ultrasonic power density and the category and consumption of catalyst were investigated. A water quality model was used to explain the degradation of different kinds of organic compounds in the coke plant wastewater by ultrasonic irradiation. After the wastewater was treated by the combined process of ultrasonic irradiation and activated sludge, the COD degradation efficiency was 95.74%, which is 63.49% higher than that by the process of activated sludge alone.

Automatic Stamping Charger---Stamping of Blended Coal-Theorical Study and Practice Analysis at TKCSA

The coke plant of a steel plant corresponds to the area that transforms a blend of coal into coke for using in blast furnace and steam to power plant. The coking plant of ThyssenKrupp CSA uses the heat recovery technology with stamping charger for stamping and preparation a blend of coals for charging and coking. Stamping technology adds several benefits to the process, such as increased density, homogeneity and alignment of the coal cake charged into the oven, as well as provides better control of the coking process, improves parameters of coke quality and allows coal blending with lower coking power, thereby reducing the production cost of coke and power generation. Through the automation of stamping charger, it is possible to evaluate and calculate the stamped coal density charged and the productivity gains this system provides.

Application of probabilistic risk assessment at a coking plant site contaminated by polycyclic aromatic hydrocarbons

Application of Probabilistic Risk Assessment （PRA） and Deterministic Risk Assessment （DRA） at a coking plant site was compared. By DRA, Hazard Quotient （HQ） following exposure to Naphthalene （Nap） and Incremental Life Cancer Risk （ILCR） following exposure to Benzo（a）pyrene （Bap） were 1.87 and 2.12 × 104. PRA revealed valuable information regarding the possible distribution of risk, and risk estimates of DRA located at the 99.59th and 99.76th percentiles in the risk outputs of PRA, which indicated that DRA overestimated the risk. Cleanup levels corresponding acceptable HQ level of 1 and ILCR level of 104 were also calculated for both DRA and PRA. Nap and Bap cleanup levels were 192.85 and 0.14mg.kg-1 by DRA, which would result in only 0.25% and 0.06% of the exposed population to have a risk higher than the acceptable risk, according to the outputs of PRA. The application of PRA on cleanup levels derivation would lift the cleanup levels 1.9 times for Nap and 2.4 times for Bap than which derived by DRA. For this coking plant site, the remediation scale and cost will be reduced in a large portion once the method of PRA is used. Sensitivity analysis was done by calculating the contribution to variance for each exposure parameter and it was found that contaminant concentration in the soil （Cs）, exposure duration （ED）, total hours spent outdoor per day （ETout）, soil ingestion rate （IRs）, the air breathing rate （IRa） and bodyweight （BW） were the most important parameters for risk and cleanup levels calculations.

Soil microbiomes divergently respond to heavy metals and polycyclic aromatic hydrocarbons in contaminated industrial sites

Contaminated sites from electronic waste(e-waste)dismantling and coking plants feature high concentrations of heavy metals(HMs)and/or polycyclic aromatic hydrocarbons(PAHs)in soil.Mixed contamination(HMsþPAHs)hinders land reclamation and affects the microbial diversity and function of soil microbiomes.In this study,we analyzed HM and PAH contamination from an e-waste dismantling plant and a coking plant and evaluated the influences of HM and PAH contamination on soil microbiomes.It was noticed that HMs and PAHs were found in all sites,although the major contaminants of the e-waste dismantling plant site were HMs(such as Cu at 5,947.58±433.44 mg kg^(-1),Zn at 4,961.38±436.51 mg kg^(-1),and Mn at 2,379.07±227.46 mg kg^(-1)),and the major contaminants of the coking plant site were PAHs(such as fluorene at 11,740.06±620.1 mg kg^(-1),acenaphthylene at 211.69±7.04 mg kg^(-1),and pyrene at 183.14±18.89 mg kg^(-1)).The microbiomes(diversity and abundance)of all sites were determined via high-throughput sequencing of 16S rRNA genes,and redundancy analysis was conducted to investigate the relations between soil microbiomes and contaminants.The results showed that the microbiomes of the contaminated sites divergently responded to HMs and PAHs.The abundances of the bacterial genera Sulfuritalea,Pseudomonas,and Sphingobium were positively related to PAHs,while the abundances of the bacterial genera Bryobacter,Nitrospira,and Steroidobacter were positively related to HMs.This study promotes an understanding of how soil microbiomes respond to single and mixed contamination with HMs and PAHs.