Cement as a building material, has high fluidity, compressive strength, and durability, but carbon dioxide emissions during cement production are a major problem. As one of the countermeasures, alkali-activated cement...Cement as a building material, has high fluidity, compressive strength, and durability, but carbon dioxide emissions during cement production are a major problem. As one of the countermeasures, alkali-activated cement using blast furnace slag powder with alkaline stimulants is considered to be a very promising solution for reducing carbon dioxide emissions, but there is a lack of information about the fundamental properties of alkali-activated materials. This study presents an experimental investigation of the fundamental properties of an alkali-activated slag system with sodium carbonate (NC) and calcium hydroxide (CH). The effects of calcium sulfo-aluminate (CSA) and shrinkage reducing agent (SRA) on the properties of blast furnace slag (BFS) based alkali-activated mixture were also investigated. In the experiments, fundamental characteristics including compressive strength, drying shrinkage, and water penetration tests of mortar were evaluated. Porosity, pH, and ignition loss were measured to verify the effectiveness of the materials. The experimental investigation revealed that the compressive strength was increased with the increasing replacement rates of NC in the BFS mortar, and in the case of water to BFS ratio of 0.45 with sodium carbonation addition contents 10 wt.%, the compressive strength for 28 days of curing reaches more than 50 MPa. Low water to BFS ratio and higher addition ratio of NC had a positive effect on the compressive strength development of mortar. Incorporating NC into BFS would affect the decrease in porosity and increase in ignition loss, leading to higher compressive strength. There was a negligible change to the compressive strength, porosity, pH, and ignition loss of BFS samples made with CH, thus, the addition rates of CH to BFS have no or little significant effect on the fundamental properties of alkali-activated cement. From the results of drying shrinkage and water penetration tests, the addition of NC and CH only to BFS exhibited poor drying shrinkage and water penetration characteristics. However, these problems may be overcome due to the use of CSA or SRA in the alkali-activated system made with NC or CH.展开更多
Cangmai 6005 is a national wheat variety approved by Cangzhou Academy of Agriculture and Forestry Sciences,which has the characteristics of drought resistance,salt tolerance,high yield and stable yield. According to t...Cangmai 6005 is a national wheat variety approved by Cangzhou Academy of Agriculture and Forestry Sciences,which has the characteristics of drought resistance,salt tolerance,high yield and stable yield. According to the characteristics of dry-alkali land in Cangzhou City and the variety characteristics,the new cultivation technique was completed.展开更多
采用碱溶酸沉的方法提取南极磷虾分离蛋白(krill protein isolate,KPI),通过喷雾干燥和冷冻干燥的方式制备南极磷虾分离蛋白粉,并对这两种分离蛋白粉的结构及功能特性进行比较分析。结果表明:与冷冻干燥南极磷虾分离蛋白(freeze-dried k...采用碱溶酸沉的方法提取南极磷虾分离蛋白(krill protein isolate,KPI),通过喷雾干燥和冷冻干燥的方式制备南极磷虾分离蛋白粉,并对这两种分离蛋白粉的结构及功能特性进行比较分析。结果表明:与冷冻干燥南极磷虾分离蛋白(freeze-dried krill protein isolate,FKPI)相比,喷雾干燥南极磷虾分离蛋白(spray-dried krill protein isolate,SKPI)明度大,色泽较好;扫描电子显微镜结果显示,SKPI呈现出向内凹陷的不规则球状结构,而FKPI为薄层片状结构,SKPI的堆积密度高于FKPI;圆二色谱进一步表明,与KPI相比,SKPI和FKPI均呈现α-螺旋含量下降、β-转角含量增加的趋势,其中,SKPI的α-螺旋含量下降27.9%,β-转角含量增加12.2%,表明喷雾干燥后蛋白质的二级结构均从有规则的结构向无规则的结构转化;SKPI持水力、持油力、乳化稳定性和起泡性等均高于FKPI,而SKPI的溶解性、乳化性却比FKPI的差。可见,不同的干燥方式会改变南极磷虾分离蛋白的结构特性,并进一步影响其功能特性。展开更多
文摘Cement as a building material, has high fluidity, compressive strength, and durability, but carbon dioxide emissions during cement production are a major problem. As one of the countermeasures, alkali-activated cement using blast furnace slag powder with alkaline stimulants is considered to be a very promising solution for reducing carbon dioxide emissions, but there is a lack of information about the fundamental properties of alkali-activated materials. This study presents an experimental investigation of the fundamental properties of an alkali-activated slag system with sodium carbonate (NC) and calcium hydroxide (CH). The effects of calcium sulfo-aluminate (CSA) and shrinkage reducing agent (SRA) on the properties of blast furnace slag (BFS) based alkali-activated mixture were also investigated. In the experiments, fundamental characteristics including compressive strength, drying shrinkage, and water penetration tests of mortar were evaluated. Porosity, pH, and ignition loss were measured to verify the effectiveness of the materials. The experimental investigation revealed that the compressive strength was increased with the increasing replacement rates of NC in the BFS mortar, and in the case of water to BFS ratio of 0.45 with sodium carbonation addition contents 10 wt.%, the compressive strength for 28 days of curing reaches more than 50 MPa. Low water to BFS ratio and higher addition ratio of NC had a positive effect on the compressive strength development of mortar. Incorporating NC into BFS would affect the decrease in porosity and increase in ignition loss, leading to higher compressive strength. There was a negligible change to the compressive strength, porosity, pH, and ignition loss of BFS samples made with CH, thus, the addition rates of CH to BFS have no or little significant effect on the fundamental properties of alkali-activated cement. From the results of drying shrinkage and water penetration tests, the addition of NC and CH only to BFS exhibited poor drying shrinkage and water penetration characteristics. However, these problems may be overcome due to the use of CSA or SRA in the alkali-activated system made with NC or CH.
基金Supported by National Key Research and Development Program of China(2017YFD0100600)
文摘Cangmai 6005 is a national wheat variety approved by Cangzhou Academy of Agriculture and Forestry Sciences,which has the characteristics of drought resistance,salt tolerance,high yield and stable yield. According to the characteristics of dry-alkali land in Cangzhou City and the variety characteristics,the new cultivation technique was completed.
文摘采用碱溶酸沉的方法提取南极磷虾分离蛋白(krill protein isolate,KPI),通过喷雾干燥和冷冻干燥的方式制备南极磷虾分离蛋白粉,并对这两种分离蛋白粉的结构及功能特性进行比较分析。结果表明:与冷冻干燥南极磷虾分离蛋白(freeze-dried krill protein isolate,FKPI)相比,喷雾干燥南极磷虾分离蛋白(spray-dried krill protein isolate,SKPI)明度大,色泽较好;扫描电子显微镜结果显示,SKPI呈现出向内凹陷的不规则球状结构,而FKPI为薄层片状结构,SKPI的堆积密度高于FKPI;圆二色谱进一步表明,与KPI相比,SKPI和FKPI均呈现α-螺旋含量下降、β-转角含量增加的趋势,其中,SKPI的α-螺旋含量下降27.9%,β-转角含量增加12.2%,表明喷雾干燥后蛋白质的二级结构均从有规则的结构向无规则的结构转化;SKPI持水力、持油力、乳化稳定性和起泡性等均高于FKPI,而SKPI的溶解性、乳化性却比FKPI的差。可见,不同的干燥方式会改变南极磷虾分离蛋白的结构特性,并进一步影响其功能特性。
