A novel kind of filter media has been studied using in biological aerated filter process which is produced by waste coal fly ash and coal gangues.The specific surface area and sum of braking and ware rate are viewed a...A novel kind of filter media has been studied using in biological aerated filter process which is produced by waste coal fly ash and coal gangues.The specific surface area and sum of braking and ware rate are viewed as the main factor for determining preparation conditions,including calcination temperature (in the range of 900 ℃ to 1250 ℃),proportion of coal gangue (in the range of 0 to 25%) and soaking time (in the range of 0 to 40 min).The effects of sintering conditions on the main property parameters are researched and the reasons have been analyzed.Considered with all factors,the optimum technological conditions are chosen as follows:the calcination temperature is 1050 ℃ ;the soaking time is 10 min and the proportion of coal gangue is 5%.When at these condition,the main property parameters of the filter media in the technological conditions are 1.6 m 2 /g for the specific surface area and 2.96 % for sum of braking and are rate respectively.Finally,a scanning electron microscope is used for analyzing the microstructure of the filter media.展开更多
For the handling, treatment and utilization of fly ash from biomass combustion its chemical composition and physical properties are important. In this study eight filter fly ashes from different grate-fired biomass co...For the handling, treatment and utilization of fly ash from biomass combustion its chemical composition and physical properties are important. In this study eight filter fly ashes from different grate-fired biomass combustion plants were investigated. In fly ash from straw combustion high concentrations of（K） were found, whereas in the fly ash from wood combustion the concentrations of Ca and Mg were higher. The average concentration of PO3-4was similar in both types of fly ashes. In all wood fly ashes some measured heavy metal concentrations were above the limits for utilization. The straw fly ashes were much less contaminated and can be utilized. For wood fly ash most parameters showed little variation, except from one fly ash where the dust pre-separator is in poor condition. The average values were： mass median diameter 4.3 ± 0.8 μm, spread of particle size distribution19 ± 11, particle density 2620 ± 80 kg/m^3 and angle of repose 50°± 1°. The density of the straw fly ashes is lower（2260 ± 80 kg/m^3） and the spread of the size distribution is higher（72 ± 24）.For one straw combustion fly ash the values of the mass median diameter and the angle of repose were similar to the values of wood combustion fly ash, for the other straw fly ash the values differed considerably. While the particle size of this fly ash was much smaller,surprisingly the angle of repose was also lower. This can be attributed to the formation of small agglomerates in this fly ash, which were not disintegrated without a certain stress.展开更多
基金Sponsored by the National High Technology Research Development Plan(863)of China(Grant No.2007AA06411)State Key Laboratory of Urban Water Resource and Environment,Harbin Institute of Technology(Grant No.2010DX05)the Critical Patented Projects in the Control and Management of the National Polluted Water Bodies(Grant No.2008ZX07207)
文摘A novel kind of filter media has been studied using in biological aerated filter process which is produced by waste coal fly ash and coal gangues.The specific surface area and sum of braking and ware rate are viewed as the main factor for determining preparation conditions,including calcination temperature (in the range of 900 ℃ to 1250 ℃),proportion of coal gangue (in the range of 0 to 25%) and soaking time (in the range of 0 to 40 min).The effects of sintering conditions on the main property parameters are researched and the reasons have been analyzed.Considered with all factors,the optimum technological conditions are chosen as follows:the calcination temperature is 1050 ℃ ;the soaking time is 10 min and the proportion of coal gangue is 5%.When at these condition,the main property parameters of the filter media in the technological conditions are 1.6 m 2 /g for the specific surface area and 2.96 % for sum of braking and are rate respectively.Finally,a scanning electron microscope is used for analyzing the microstructure of the filter media.
文摘For the handling, treatment and utilization of fly ash from biomass combustion its chemical composition and physical properties are important. In this study eight filter fly ashes from different grate-fired biomass combustion plants were investigated. In fly ash from straw combustion high concentrations of（K） were found, whereas in the fly ash from wood combustion the concentrations of Ca and Mg were higher. The average concentration of PO3-4was similar in both types of fly ashes. In all wood fly ashes some measured heavy metal concentrations were above the limits for utilization. The straw fly ashes were much less contaminated and can be utilized. For wood fly ash most parameters showed little variation, except from one fly ash where the dust pre-separator is in poor condition. The average values were： mass median diameter 4.3 ± 0.8 μm, spread of particle size distribution19 ± 11, particle density 2620 ± 80 kg/m^3 and angle of repose 50°± 1°. The density of the straw fly ashes is lower（2260 ± 80 kg/m^3） and the spread of the size distribution is higher（72 ± 24）.For one straw combustion fly ash the values of the mass median diameter and the angle of repose were similar to the values of wood combustion fly ash, for the other straw fly ash the values differed considerably. While the particle size of this fly ash was much smaller,surprisingly the angle of repose was also lower. This can be attributed to the formation of small agglomerates in this fly ash, which were not disintegrated without a certain stress.
