Background： The aim of this study was to optimize the fungal treatment of lignocellulosic biomass by stimulating the colonization. Wheat straw and wood chips were treated with Ceriporiopsis subvermispora and Lentinul...Background： The aim of this study was to optimize the fungal treatment of lignocellulosic biomass by stimulating the colonization. Wheat straw and wood chips were treated with Ceriporiopsis subvermispora and Lentinula edodes with various amounts of colonized millet grains（0.5, 1.5 or 3.0 % per g of wet weight of substrate） added to the substrates. Also, wheat straw and wood chips were chopped to either 0.5 or 2 cm.Effectiveness of the fungal treatment after 0, 2, 4, 6, or 8 wk of incubation was determined by changes in chemical composition, in vitro gas production（IVGP） as a measure for rumen degradability, and ergosterol content as a measure of fungal biomass.Results： Incomplete colonization was observed for C. subvermispora treated wheat straw and L. edodes treated wood chips. The different particle sizes and amounts of inoculum tested, had no significant effects on the chemical composition and the IVGP of C. subvermispora treated wood chips. Particle size did influence L.edodes treatment of wheat straw. The L. edodes treatment of 2 cm wheat straw resulted in a more selective delignification and a higher IVGP than the smaller particles. Addition of 1.5 % or 3 % L. edodes inoculum to wheat straw resulted in more selective delignification and a higher IVGP than addition of 0.5 % inoculum.Conclusion： Particle size and amount of inoculum did not have an effect on C. subvermispora treatment of wood chips. At least 1.5 % L. edodes colonized millet grains should be added to 2 cm wheat straw to result in an increased IVGP and acid detergent lignin（ADL） degradation.展开更多
Brown seaweed, Sargassum spp. is also used as an alternative feed ingredient for aquaculture in the form of seaweed meal. Nutritional values seaweed meal with bioprocess technology using microbes such as Lactobacillus...Brown seaweed, Sargassum spp. is also used as an alternative feed ingredient for aquaculture in the form of seaweed meal. Nutritional values seaweed meal with bioprocess technology using microbes such as Lactobacillus, Bacillus or Streptococcus, are improved with different inoculum sizes. Purple non-sulphur bacterium, Afifella marina could be one of the alternative and potential candidates. This study aims to determine the optimum inoculum level and period for the improvement of nutritional values in Sargassum polycystum meal. Sargassum polycystum was collected from the Sepanggar Bay. Dried seaweed was grinded into fine particles (A. marina were used with 20 g Sargassum polycystum powder in one liter bottle with autoclaved 112 synthetic media. Bottles were incubated at 2500 lux light intensity at 30˚C ± 1˚C for 8 days. Every two days destructive samples were taken for the determination of nutritional values of bioprocessed seaweed meal. The measured analytical parameters were crude protein (%), crude ash (%), crude fiber (%) and crude lipids (%). Nutritional value of processed seaweed meal powder with A. marina has improved with the increase of inoculum size. The crude protein percentage of 14.70% + 0.40% was significantly high (p 0.05) were observed among the values of crude protein, ash, lipids and fiber within 6<sup>th</sup> and 8<sup>th</sup> day. A. mariana with 30% (v/v) inoculum sizes on 6<sup>th</sup> of day has capability in improving the nutritional values of Sargassum polycystum seaweed meal during bioprocessing.展开更多
以残留在筛网上的菌丝密集度为指标,确定了菌丝的最佳打碎时间为2 min。然后以杏鲍菇菌丝生长深度为指标,分别研究了打碎后的纯菌种稀释倍数和接种量对杏鲍菇菌丝生长的影响。结果表明:纯菌种最佳稀释倍数为500倍,最佳接种量为20 m L/...以残留在筛网上的菌丝密集度为指标,确定了菌丝的最佳打碎时间为2 min。然后以杏鲍菇菌丝生长深度为指标,分别研究了打碎后的纯菌种稀释倍数和接种量对杏鲍菇菌丝生长的影响。结果表明:纯菌种最佳稀释倍数为500倍,最佳接种量为20 m L/袋。此研究为筛选适用工厂化生产的液体菌种技术提供了理论依据。展开更多
基金supported by the Dutch Technology Foundation (STW)which is part of the Netherlands Organization for Scientific Research (NWO)+1 种基金which is partly funded by the Dutch Ministry of Economic Affairsproject (11611) was co-sponsored by Agrifirm, Purac, DSM, Den Ouden, Hofmans, the Dutch commodity boards for dairy and horticulture, and Wageningen University
文摘Background： The aim of this study was to optimize the fungal treatment of lignocellulosic biomass by stimulating the colonization. Wheat straw and wood chips were treated with Ceriporiopsis subvermispora and Lentinula edodes with various amounts of colonized millet grains（0.5, 1.5 or 3.0 % per g of wet weight of substrate） added to the substrates. Also, wheat straw and wood chips were chopped to either 0.5 or 2 cm.Effectiveness of the fungal treatment after 0, 2, 4, 6, or 8 wk of incubation was determined by changes in chemical composition, in vitro gas production（IVGP） as a measure for rumen degradability, and ergosterol content as a measure of fungal biomass.Results： Incomplete colonization was observed for C. subvermispora treated wheat straw and L. edodes treated wood chips. The different particle sizes and amounts of inoculum tested, had no significant effects on the chemical composition and the IVGP of C. subvermispora treated wood chips. Particle size did influence L.edodes treatment of wheat straw. The L. edodes treatment of 2 cm wheat straw resulted in a more selective delignification and a higher IVGP than the smaller particles. Addition of 1.5 % or 3 % L. edodes inoculum to wheat straw resulted in more selective delignification and a higher IVGP than addition of 0.5 % inoculum.Conclusion： Particle size and amount of inoculum did not have an effect on C. subvermispora treatment of wood chips. At least 1.5 % L. edodes colonized millet grains should be added to 2 cm wheat straw to result in an increased IVGP and acid detergent lignin（ADL） degradation.
文摘Brown seaweed, Sargassum spp. is also used as an alternative feed ingredient for aquaculture in the form of seaweed meal. Nutritional values seaweed meal with bioprocess technology using microbes such as Lactobacillus, Bacillus or Streptococcus, are improved with different inoculum sizes. Purple non-sulphur bacterium, Afifella marina could be one of the alternative and potential candidates. This study aims to determine the optimum inoculum level and period for the improvement of nutritional values in Sargassum polycystum meal. Sargassum polycystum was collected from the Sepanggar Bay. Dried seaweed was grinded into fine particles (A. marina were used with 20 g Sargassum polycystum powder in one liter bottle with autoclaved 112 synthetic media. Bottles were incubated at 2500 lux light intensity at 30˚C ± 1˚C for 8 days. Every two days destructive samples were taken for the determination of nutritional values of bioprocessed seaweed meal. The measured analytical parameters were crude protein (%), crude ash (%), crude fiber (%) and crude lipids (%). Nutritional value of processed seaweed meal powder with A. marina has improved with the increase of inoculum size. The crude protein percentage of 14.70% + 0.40% was significantly high (p 0.05) were observed among the values of crude protein, ash, lipids and fiber within 6<sup>th</sup> and 8<sup>th</sup> day. A. mariana with 30% (v/v) inoculum sizes on 6<sup>th</sup> of day has capability in improving the nutritional values of Sargassum polycystum seaweed meal during bioprocessing.
