An investigation on phase distribution in air-water two-phase flow in horizontal circular channel was conducted by using the double-sensor resistivity probe.The variations of phase distribution with variations of gas ...An investigation on phase distribution in air-water two-phase flow in horizontal circular channel was conducted by using the double-sensor resistivity probe.The variations of phase distribution with variations of gas and liquid volumetric fluxes were analyzed and the present data were compared with some of other researcher’s data and existing models. It was found there exists more complicated phase distribution pattern in horizontal flow system than in vertical flow. The radial local void fraction profiles are similar at the same measurement angle with various gas and liquid flow rates. However, an asymmetric profile can be observed at a given slice of the pipe cross-section.展开更多
There are contradicted opinions on whether bubbles enhance or reduce the liquid turbulence. In this paper, the effect of void fraction and inlet velocity on the bubble-liquid two-phase turbulence of the multiple bubbl...There are contradicted opinions on whether bubbles enhance or reduce the liquid turbulence. In this paper, the effect of void fraction and inlet velocity on the bubble-liquid two-phase turbulence of the multiple bubble-liquid jets in a two-dimensional channel is studied by using the two-phase second-order moment turbulence model. The results confirm the phenomena observed in experiments and reported in references that at a low void fraction and low inlet velocities the bubbles enhance the liquid turbulence, whereas at a high void fraction and high inlet velocities the bubbles reduce the liquid turbulence.展开更多
This paper is concerned with a remedy for interface smearing,which is usable when fixed (i.e. non moving and so non conforming) grids are employed. It is simple to employ and has been found to be rather effective. T...This paper is concerned with a remedy for interface smearing,which is usable when fixed (i.e. non moving and so non conforming) grids are employed. It is simple to employ and has been found to be rather effective. The paper explains its principle, describes how it has been implemented and presents some results obtained with its assistance. The results are compared both with those of earlier methods of interface motion calculation and with experimental data.展开更多
Based on the momentum conservation approach, a theoretical model was developed to predict the superficial liquid velocity, and a correlation equation was established to calculate the gas holdup of an annular external-...Based on the momentum conservation approach, a theoretical model was developed to predict the superficial liquid velocity, and a correlation equation was established to calculate the gas holdup of an annular external-loop airlift reactor(AELAR)in the bubble flow and developing slug flow pattern. Experiments were performed by using tap-water and silicone oil with the viscosity of 2.0 mm^2/s(2cs-SiO)and 5.0 mm^2/s(5cs-SiO)as liquid phases. The effects of liquid viscosity and flow pattern on the AELAR performance were investigated. The predictions of the proposed model were in good agreement with the experimental results of the AELAR. In addition, the comparison of the experimental results shows that the proposed model has good accuracy and could be used to predict the gas holdup and liquid velocity of an AELAR operating in bubble and developing flow pattern.展开更多
In this paper,an improved computational fluid dynamic(CFD)model for gas-liquid flow in bubble column was developed using the one-equation Wary-Agarwal(WA)turbulence model coupled with the population balance model(PBM)...In this paper,an improved computational fluid dynamic(CFD)model for gas-liquid flow in bubble column was developed using the one-equation Wary-Agarwal(WA)turbulence model coupled with the population balance model(PBM).Through 18 orthogonal test cases,the optimal combination of interfacial force models,including drag force,lift force,turbulent dispersion force.The modified wall lubrication force model was proposed to improve the predictive ability for hydrodynamic behavior near the wall of the bubble column.The values simulated by optimized CFD model were in agreement with experimental data,and the errors were within±20%.In addition,the axial velocity,turbulent kinetic energy,bubble size distribution,and the dynamic characteristic of bubble plume were analyzed at different superficial gas velocities.This research work could provide a theoretical basis for the extension of the CFD-PBM coupled model to other multiphase reactors..展开更多
Aim To develop a hydrodynamic model on the void fraction in liquid slugs for gas liquid slug flow in vertical tubes. Methods Developing the model by considering the gas exchange between the Taylor bubble and the fo...Aim To develop a hydrodynamic model on the void fraction in liquid slugs for gas liquid slug flow in vertical tubes. Methods Developing the model by considering the gas exchange between the Taylor bubble and the following liquid slug. Results Some experimental data are obtained to check the model. In comparison with previous published results, the predictions from this model are better and in good agreement with the experimental data. The error is within ±20%. Conclusion The proposed model can correctly predict the void fraction in liquid slugs for gas liquid two phase slug flow in vertical tubes.展开更多
This paper deal with the frictional resistance characteristics of gas liquid two phase flow in vertical upward helical coiled tubes under the system pressure 0.1 0.6MPa. By means of dimension analysis and π theo...This paper deal with the frictional resistance characteristics of gas liquid two phase flow in vertical upward helical coiled tubes under the system pressure 0.1 0.6MPa. By means of dimension analysis and π theorem, the correlation formulas were obtained for calculating the frictional resistance coefficients of gas liquid two phase flow in helical coiled tubes. The calculated results agree well with the experimental results.展开更多
文摘An investigation on phase distribution in air-water two-phase flow in horizontal circular channel was conducted by using the double-sensor resistivity probe.The variations of phase distribution with variations of gas and liquid volumetric fluxes were analyzed and the present data were compared with some of other researcher’s data and existing models. It was found there exists more complicated phase distribution pattern in horizontal flow system than in vertical flow. The radial local void fraction profiles are similar at the same measurement angle with various gas and liquid flow rates. However, an asymmetric profile can be observed at a given slice of the pipe cross-section.
基金The project supported by the China Special Funds for Major State Basic Research (G-1999-0222-08)the Innovation and Technology Commission of Hong Kong and Aoyagi (H.K.) Ltd, Hong Kong, under the Grant No. UIM/122.
文摘There are contradicted opinions on whether bubbles enhance or reduce the liquid turbulence. In this paper, the effect of void fraction and inlet velocity on the bubble-liquid two-phase turbulence of the multiple bubble-liquid jets in a two-dimensional channel is studied by using the two-phase second-order moment turbulence model. The results confirm the phenomena observed in experiments and reported in references that at a low void fraction and low inlet velocities the bubbles enhance the liquid turbulence, whereas at a high void fraction and high inlet velocities the bubbles reduce the liquid turbulence.
文摘This paper is concerned with a remedy for interface smearing,which is usable when fixed (i.e. non moving and so non conforming) grids are employed. It is simple to employ and has been found to be rather effective. The paper explains its principle, describes how it has been implemented and presents some results obtained with its assistance. The results are compared both with those of earlier methods of interface motion calculation and with experimental data.
基金Supported by the National Natural Science Foundation of China(No.51478297)Program of Introducing Talents of Discipline(No.B13011)
文摘Based on the momentum conservation approach, a theoretical model was developed to predict the superficial liquid velocity, and a correlation equation was established to calculate the gas holdup of an annular external-loop airlift reactor(AELAR)in the bubble flow and developing slug flow pattern. Experiments were performed by using tap-water and silicone oil with the viscosity of 2.0 mm^2/s(2cs-SiO)and 5.0 mm^2/s(5cs-SiO)as liquid phases. The effects of liquid viscosity and flow pattern on the AELAR performance were investigated. The predictions of the proposed model were in good agreement with the experimental results of the AELAR. In addition, the comparison of the experimental results shows that the proposed model has good accuracy and could be used to predict the gas holdup and liquid velocity of an AELAR operating in bubble and developing flow pattern.
基金supported by the National Natural Science Foundation of China(22078009)National Key Research and Development Program of China(2021YFC3001102,2021YFC3001100)。
文摘In this paper,an improved computational fluid dynamic(CFD)model for gas-liquid flow in bubble column was developed using the one-equation Wary-Agarwal(WA)turbulence model coupled with the population balance model(PBM).Through 18 orthogonal test cases,the optimal combination of interfacial force models,including drag force,lift force,turbulent dispersion force.The modified wall lubrication force model was proposed to improve the predictive ability for hydrodynamic behavior near the wall of the bubble column.The values simulated by optimized CFD model were in agreement with experimental data,and the errors were within±20%.In addition,the axial velocity,turbulent kinetic energy,bubble size distribution,and the dynamic characteristic of bubble plume were analyzed at different superficial gas velocities.This research work could provide a theoretical basis for the extension of the CFD-PBM coupled model to other multiphase reactors..
文摘Aim To develop a hydrodynamic model on the void fraction in liquid slugs for gas liquid slug flow in vertical tubes. Methods Developing the model by considering the gas exchange between the Taylor bubble and the following liquid slug. Results Some experimental data are obtained to check the model. In comparison with previous published results, the predictions from this model are better and in good agreement with the experimental data. The error is within ±20%. Conclusion The proposed model can correctly predict the void fraction in liquid slugs for gas liquid two phase slug flow in vertical tubes.
文摘This paper deal with the frictional resistance characteristics of gas liquid two phase flow in vertical upward helical coiled tubes under the system pressure 0.1 0.6MPa. By means of dimension analysis and π theorem, the correlation formulas were obtained for calculating the frictional resistance coefficients of gas liquid two phase flow in helical coiled tubes. The calculated results agree well with the experimental results.
