Traditional solvent recovery in the extraction step of edible oil processing is distillation,which consumes large amounts of energy.If the distillation is replaced by membrane process,the energy consumption can be red...Traditional solvent recovery in the extraction step of edible oil processing is distillation,which consumes large amounts of energy.If the distillation is replaced by membrane process,the energy consumption can be reduced greatly.In this work,two kinds of membrane,PDMS(polydimethylsiloxane) composite membrane and Zeolite filled PDMS membrane were prepared,in which asymmetric microporous PVDF(polyvinylidenefluoride) membrane prepared with phase inversion method was functioned as the microporous supporting layer in the flat-plate composite membrane.The different function compositions of the PDMS/PVDF composite membranes were characterized by reflection Fourier transform infrared(FTIR) spectroscopy.The surface and section of PDMS/PVDF composite membranes were investigated by scanning electron microscope(SEM).The PDMS NF(nanofiltration) membranes were then applied in the recovery of hexane from soybean oil/hexane miscellas(1:3,mass ratio).The effects of pressure(0.5-1.5 MPa),cross-linking temperature and PDMS layer thickness on membrane performances were investigated.The results indicated that both two kinds of NF membranes were promising for solvent recovery,and zeolite filled in PDMS NF membrane could enhance the separation performance.展开更多
India has the highest utilization of rice bran oil in terms of the available resources in the country.Parboiled rice tradition has made the available rice bran in relatively good quality.This makes the quality of crud...India has the highest utilization of rice bran oil in terms of the available resources in the country.Parboiled rice tradition has made the available rice bran in relatively good quality.This makes the quality of crude rice bran oil being also high.Therefore the following processing is made relatively simple comparing with those high free fatty acid content crude rice bran oils.In India,physical refining is commonly used.Thus the oil refining yield is usually high.The unsaponifiable content is also higher comparatively.For example,oryzanol content is usually 1%to 1.5%in weight.Although there are a large number of rice bran oil small plants in India,the technology is relatively mature for the production of relatively good quality rice bran oil.In this short overview of the production technology of rice bran oil in India,the state of the art has been elaborated in a simple form.Particularly,the problems and challenges of the production technology have been evaluated with the background of decades of research and technology development work in India.展开更多
研究了铁核桃油膜法脱胶工艺及其对铁核桃油品质的影响。分别采用Plackett-Burman实验和响应面实验对铁核桃油膜法脱胶工艺进行优化。结果表明:铁核桃油膜法脱胶的最佳工艺条件为膜孔径10 k Da、溶油比3∶1、操作压力0.25 MPa,在此条件...研究了铁核桃油膜法脱胶工艺及其对铁核桃油品质的影响。分别采用Plackett-Burman实验和响应面实验对铁核桃油膜法脱胶工艺进行优化。结果表明:铁核桃油膜法脱胶的最佳工艺条件为膜孔径10 k Da、溶油比3∶1、操作压力0.25 MPa,在此条件下膜法脱胶后铁核桃油中磷脂含量从755.603 mg/kg降为16.25 mg/kg,脱胶率为97.85%。与水化脱胶相比,膜法脱胶后铁核桃油中V_E和植物甾醇的含量高,氧化诱导时间长。展开更多
基金Supported by the State Key Development Program for Basic Research of China （2009CB623404） the National Natural Science Foundation of China （20736003 20906056） the National High Technology Research and Development Program of China （2007AA06Z317 2008EG111021）
文摘Traditional solvent recovery in the extraction step of edible oil processing is distillation,which consumes large amounts of energy.If the distillation is replaced by membrane process,the energy consumption can be reduced greatly.In this work,two kinds of membrane,PDMS(polydimethylsiloxane) composite membrane and Zeolite filled PDMS membrane were prepared,in which asymmetric microporous PVDF(polyvinylidenefluoride) membrane prepared with phase inversion method was functioned as the microporous supporting layer in the flat-plate composite membrane.The different function compositions of the PDMS/PVDF composite membranes were characterized by reflection Fourier transform infrared(FTIR) spectroscopy.The surface and section of PDMS/PVDF composite membranes were investigated by scanning electron microscope(SEM).The PDMS NF(nanofiltration) membranes were then applied in the recovery of hexane from soybean oil/hexane miscellas(1:3,mass ratio).The effects of pressure(0.5-1.5 MPa),cross-linking temperature and PDMS layer thickness on membrane performances were investigated.The results indicated that both two kinds of NF membranes were promising for solvent recovery,and zeolite filled in PDMS NF membrane could enhance the separation performance.
文摘India has the highest utilization of rice bran oil in terms of the available resources in the country.Parboiled rice tradition has made the available rice bran in relatively good quality.This makes the quality of crude rice bran oil being also high.Therefore the following processing is made relatively simple comparing with those high free fatty acid content crude rice bran oils.In India,physical refining is commonly used.Thus the oil refining yield is usually high.The unsaponifiable content is also higher comparatively.For example,oryzanol content is usually 1%to 1.5%in weight.Although there are a large number of rice bran oil small plants in India,the technology is relatively mature for the production of relatively good quality rice bran oil.In this short overview of the production technology of rice bran oil in India,the state of the art has been elaborated in a simple form.Particularly,the problems and challenges of the production technology have been evaluated with the background of decades of research and technology development work in India.
