Enhancing cavern sealing is crucial for improving the efficiency of compressed air energy storage(CAES)in hard rock formations.This study introduced a novel approach using a nano-grade organosilicon polymer(NOSP)as a ...Enhancing cavern sealing is crucial for improving the efficiency of compressed air energy storage(CAES)in hard rock formations.This study introduced a novel approach using a nano-grade organosilicon polymer(NOSP)as a sealant,coupled with an air seepage evaluation model that incorporates Knudsen diffusion.Moreover,the initial coating application methods were outlined,and the advantages of using NOSP compared to other sealing materials,particularly regarding cost and construction techniques,were also examined and discussed.Experimental results indicated a significant reduction in permeability of rock specimens coated with a 7–10μm thick NOSP layer.Specifically,under a 0.5 MPa pulse pressure,the permeability decreased to less than 1 n D,and under a 4 MPa pulse pressure,it ranged between4.5×10^(-6)–5.5×10^(-6)m D,marking a 75%–80%decrease in granite permeability.The sealing efficacy of NOSP surpasses concrete and is comparable to rubber materials.The optimal viscosity for application lies between 95 and 105 KU,and the coating thickness should ideally range from 7 to 10μm,applied to substrates with less than 3%porosity.This study provides new insights into air transport and sealing mechanisms at the pore level,proposing NOSP as a cost-effective and simplified solution for CAES applications.展开更多
The evolution of electronic communication technology raises higher requirements for low dielectric constant(low-k)materials.For this,a benzoxazine functional organosilicon(HP-aptes)with dense Si—O—Si crosslinking ne...The evolution of electronic communication technology raises higher requirements for low dielectric constant(low-k)materials.For this,a benzoxazine functional organosilicon(HP-aptes)with dense Si—O—Si crosslinking networks and large sterically hindered tert-butyl groups was prepared by the sol–gel method.Then,a series of polybenzoxazine composites(PPHP)were prepared from intrinsically low dielectric constant bis-functional benzoxazine monomer(P-aptmds)and HP-aptes.The double crosslinking networks of polybenzoxazine and organosilicon further increased the crosslinking density and decreased the dipole density of composites,which endowed the composites with enhanced low-k properties.When the content of HP-aptes is 30%(mass),the crosslinking density was 2.05×10^(-3)mol·cm^(-3),while that of PP-aptmds was 3.31×10^(-3)mol·cm^(-3).In addition,the dielectric constant and dielectric loss of PPHP composite at 1 MHz could reach 2.61 and 0.0056,respectively.展开更多
The flotation of diaspore and three kinds of silicate minerals, including kaolinite, illite and pyrophyllite, using an organosilicon cationic surfactant (TAS101) as collector and starch as depressant was investigated....The flotation of diaspore and three kinds of silicate minerals, including kaolinite, illite and pyrophyllite, using an organosilicon cationic surfactant (TAS101) as collector and starch as depressant was investigated. The results show that both diaspore and aluminosilicate minerals float readily with organosilicon cationic collector TAS101 at pH values of 4 to 10. Starch has a strong depression effect for diaspore in the alkaline pH region but has little influence on the flotation of aluminosilicate minerals. It is possible to separate diaspore from aluminosilicate minerals using the organosilicon cationic collector and starch depressant. Further studies of bauxite ore flotation were also conducted, and the reverse flotation separation process was adopted. The concentrates with the mass ratio of Al2O3 to SiO2 of 9.58 and Al2O3 recovery of 83.34% are obtained from natural bauxite ore with the mass ratio of Al2O3 to SiO2 of 6.1 at pH value of 11 using the organosilicon cationic collector and starch depressant.展开更多
[Objective] The aim was to explore effects of chitosan and organosilicon on tomato resistance against Botrytis cinerea. [Method] With leaf spraying method adopted, four groups were set in the test, including control g...[Objective] The aim was to explore effects of chitosan and organosilicon on tomato resistance against Botrytis cinerea. [Method] With leaf spraying method adopted, four groups were set in the test, including control group, groups treated with Botrytis cinerea, with chitosan and Botrytis cinerea, and with chitosan, organosilicon, and Botrytis cinerea, in order to study on effects of chitosan and organosilicon on antioxidant enzyme activities of tomato. [Result] Antioxidant enzyme activities of tomato seedlings were improved in groups with chitosan, organosilicon, and Botrytis cinerea and with chitosan and Botrytis cinerea compared with the group treated with Botrytis cinerea. On the 6th d, activities of PAL, SOD, POD, PPO and CAT in groups with chitosan and Botrytis cinerea, and with chitosan, organosilicon, and Botrytis cinerea increased by 27.36%, 52.07%, 43.55%, 82.02% and 71.82%, and 18.91%, 30.22%, 57.14%, 38.09% and 53.64%, respectively. [Conclusion] Antioxidant enzyme activities of tomato seedlings could be improved by chitosan and organosilicon.展开更多
The deposition of organosilicone thin films from hexamethyldisiloxane（HMDSO） by using a dual-frequency （50 kHz/33 MHz） atmospheric-pressure micro-plasma jet with an admixture of a small volume of HMDSO and Ar was ...The deposition of organosilicone thin films from hexamethyldisiloxane（HMDSO） by using a dual-frequency （50 kHz/33 MHz） atmospheric-pressure micro-plasma jet with an admixture of a small volume of HMDSO and Ar was investigated.The topography was measured by using scanning electron microscopy.The chemical bond and composition of these films were analyzed by Fourier transform infrared spectroscopy （FTIR） and x-ray photoelectron spectroscopy.The results indicated that the as-deposited film was constituted by silicon,carbon,and oxygen elements,and FTIR suggested the films are organosilicon with the organic component （-CHx） and hydroxyl functional group（-OH） connected to the Si-O-Si backbone.Thin-film hardness was recorded by an MH-5-VM Digital Micro-Hardness Tester.Radio frequency power had a strong impact on film hardness and the hardness increased with increasing power.展开更多
Based on determination for surface tension of organosilicone solution and its expansion on the solid surface, the biological activity of 5% emameetin ben- zoate WDG with organosilicone against beet armyworm was determ...Based on determination for surface tension of organosilicone solution and its expansion on the solid surface, the biological activity of 5% emameetin ben- zoate WDG with organosilicone against beet armyworm was determined by spraying method to study their synergistic activity. The results showed that organosilicone significandy reduced surface tension of aqueous solution, and the surface tension was reduced to 26raN/m as the concentration of organosilicone was 0.01%. The organosilicone significantly raised expansion of liquid drops on solid surface, and the expansion diameter of 10 μL 0.01% organosilicone was 34 ram. The indoor toxicity results indicated that when addition dosage of organosilieone was 1% -5%, synergistic activity of 5% emamectin benzoate WDG with organosilicone against beet armyworm was significant, and increase extent of synergistic activity slowed down as organosilieone dosage was higher than 5%. Field experiment showed that the control efficacies of 5% emamectin benzoate WDG ＋5% organosilicone 33 mg/ L against beet armyworm were 81.57% and 82.66% after spraying for 3 and 7 d respectively, which were significandy better than treatments of 5% emamectin benzoate WDG 33 rag/L, 24% metaflumizone SC 96 mg/L, 5% chlorantranilip- role SC 33 mg/L, 20% tlubendiamide WDG 40 mg/L and 15% indoxacarb EC 43 mg/L.展开更多
Immobilization of active molecules by attachment onto solid surfaces is a well-established practice in many processes and applications. Silica micro- and nano-particles are attractive candidates as support for active ...Immobilization of active molecules by attachment onto solid surfaces is a well-established practice in many processes and applications. Silica micro- and nano-particles are attractive candidates as support for active molecules as a result of a combination of desirable properties. The present study deals with grafting of a functional UV active molecule onto silica surfaces via hydrosilylation reactions using multivalent organosilicon spacers. Different types of organosilicon precursors based on dimethylsiloxysilanes containing multiple SiH groups were used as spacers between vinyl-modified silica surface and the benzotriazole UV-absorber (UVA). Firstly, the surface of silica was modified with vinyltrimetoxsisilane coupling agent. The UVA molecules were attached to the silica-vinyl by a two-step procedure involving hydrosilylation reaction. The successful grafting was confirmed by FTIR, TGA and UV-Vis characterization. More than fivefold increase in UVA loading was found for the MH30 multifunctional spacer, which contains approximately 75 SiH groups per molecule, when compared to a four-functional spacer. Furthermore a branched, bulky six-functional spacer is preferred over a linear spacer of the same functionality. UV activity of functionalized silica was studied by UV-Vis spectroscopy, indicating that the immobilization of UVA onto silica surface has not altered its UV absorbance properties.展开更多
Comprehensive Summary,Low dielectric(low-k)organosilicon polymers have received extensive interests from industry and academia due to good electrical insulation,high temperature resistance,flame retardancy and hydroph...Comprehensive Summary,Low dielectric(low-k)organosilicon polymers have received extensive interests from industry and academia due to good electrical insulation,high temperature resistance,flame retardancy and hydrophobicity.These attractive properties enable them to be utilized as low-k materials in fabrication of electronic devices in high-frequency communication technology.This review summarizes recent progress in developing low-k organosilicon polymers,including the synthetic methods and properties of different organosilicon polymers classified according to the chemical structures.It may provide some inspiration to design new low-k organosilicon polymers for application in the.展开更多
In the realm of the synthesis of heat-integrated distillation configurations,the conventional approach for exploring more heat integration possibilities typically entails the splitting of a single column into a twocol...In the realm of the synthesis of heat-integrated distillation configurations,the conventional approach for exploring more heat integration possibilities typically entails the splitting of a single column into a twocolumn configuration.However,this approach frequently necessitates tedious enumeration procedures,resulting in a considerable computational burden.To surmount this formidable challenge,the present study introduces an innovative remedy:The proposition of a superstructure that encompasses both single-column and multiple two-column configurations.Additionally,a simultaneous optimization algorithm is applied to optimize both the process parameters and heat integration structures of the twocolumn configurations.The effectiveness of this approach is demonstrated through a case study focusing on industrial organosilicon separation.The results underscore that the superstructure methodology not only substantially mitigates computational time compared to exhaustive enumeration but also furnishes solutions that exhibit comparable performance.展开更多
本文开展了有机硅改性酚醛树脂复合材料制备及性能研究。首先进行有机硅改性酚醛树脂复合材料的制备:将4 g甲基苯基二甲氧基硅烷溶于25 m L四甲基氢氧化铵中,然后将得到的料液添至去离子水中进行搅拌,得到黄色固体,并将其置于60℃烘箱中...本文开展了有机硅改性酚醛树脂复合材料制备及性能研究。首先进行有机硅改性酚醛树脂复合材料的制备:将4 g甲基苯基二甲氧基硅烷溶于25 m L四甲基氢氧化铵中,然后将得到的料液添至去离子水中进行搅拌,得到黄色固体,并将其置于60℃烘箱中,设置时间24 h,得出有机硅改性酚醛树脂复合材料。再者,对有机硅改性酚醛树脂复合材料的热性能及复合材料层间剪切强度进行测试。研究结果表明:当固化环氧树脂和固化剂质量比为95∶5时,有机硅改性酚醛树脂复合材料性能最优,此时其层间剪切强度高达87.5 MPa,热失重质量为0.22 g,耐热性能更好。展开更多
基金supported by the National Natural Science Foundation of China(No.42272321)Hubei Provincial Key Research Projects(Nos.2022BAA093 and 2022BAD163)+1 种基金Major Scientific and Technological Special Project of Jiangxi Province(No.2023ACG01004)WSGRI Engineering&Surveying Incorporation Limited(No.6120230256)。
文摘Enhancing cavern sealing is crucial for improving the efficiency of compressed air energy storage(CAES)in hard rock formations.This study introduced a novel approach using a nano-grade organosilicon polymer(NOSP)as a sealant,coupled with an air seepage evaluation model that incorporates Knudsen diffusion.Moreover,the initial coating application methods were outlined,and the advantages of using NOSP compared to other sealing materials,particularly regarding cost and construction techniques,were also examined and discussed.Experimental results indicated a significant reduction in permeability of rock specimens coated with a 7–10μm thick NOSP layer.Specifically,under a 0.5 MPa pulse pressure,the permeability decreased to less than 1 n D,and under a 4 MPa pulse pressure,it ranged between4.5×10^(-6)–5.5×10^(-6)m D,marking a 75%–80%decrease in granite permeability.The sealing efficacy of NOSP surpasses concrete and is comparable to rubber materials.The optimal viscosity for application lies between 95 and 105 KU,and the coating thickness should ideally range from 7 to 10μm,applied to substrates with less than 3%porosity.This study provides new insights into air transport and sealing mechanisms at the pore level,proposing NOSP as a cost-effective and simplified solution for CAES applications.
基金the Innovation Program of the Shanghai Municipal Education Commission(2019-01-07-00-02-E00061)the Shanghai Municipal Science and Technology Commission(21520761100).
文摘The evolution of electronic communication technology raises higher requirements for low dielectric constant(low-k)materials.For this,a benzoxazine functional organosilicon(HP-aptes)with dense Si—O—Si crosslinking networks and large sterically hindered tert-butyl groups was prepared by the sol–gel method.Then,a series of polybenzoxazine composites(PPHP)were prepared from intrinsically low dielectric constant bis-functional benzoxazine monomer(P-aptmds)and HP-aptes.The double crosslinking networks of polybenzoxazine and organosilicon further increased the crosslinking density and decreased the dipole density of composites,which endowed the composites with enhanced low-k properties.When the content of HP-aptes is 30%(mass),the crosslinking density was 2.05×10^(-3)mol·cm^(-3),while that of PP-aptmds was 3.31×10^(-3)mol·cm^(-3).In addition,the dielectric constant and dielectric loss of PPHP composite at 1 MHz could reach 2.61 and 0.0056,respectively.
基金Project(51304085)supported by the National Natural Science Foundation of ChinaProject(GJJ12363)supported by the Education Department of Jiangxi Province,ChinaProject(20142BAB216021)supported by the Natural Science Foundation of Jiangxi Province,China
文摘The flotation of diaspore and three kinds of silicate minerals, including kaolinite, illite and pyrophyllite, using an organosilicon cationic surfactant (TAS101) as collector and starch as depressant was investigated. The results show that both diaspore and aluminosilicate minerals float readily with organosilicon cationic collector TAS101 at pH values of 4 to 10. Starch has a strong depression effect for diaspore in the alkaline pH region but has little influence on the flotation of aluminosilicate minerals. It is possible to separate diaspore from aluminosilicate minerals using the organosilicon cationic collector and starch depressant. Further studies of bauxite ore flotation were also conducted, and the reverse flotation separation process was adopted. The concentrates with the mass ratio of Al2O3 to SiO2 of 9.58 and Al2O3 recovery of 83.34% are obtained from natural bauxite ore with the mass ratio of Al2O3 to SiO2 of 6.1 at pH value of 11 using the organosilicon cationic collector and starch depressant.
文摘[Objective] The aim was to explore effects of chitosan and organosilicon on tomato resistance against Botrytis cinerea. [Method] With leaf spraying method adopted, four groups were set in the test, including control group, groups treated with Botrytis cinerea, with chitosan and Botrytis cinerea, and with chitosan, organosilicon, and Botrytis cinerea, in order to study on effects of chitosan and organosilicon on antioxidant enzyme activities of tomato. [Result] Antioxidant enzyme activities of tomato seedlings were improved in groups with chitosan, organosilicon, and Botrytis cinerea and with chitosan and Botrytis cinerea compared with the group treated with Botrytis cinerea. On the 6th d, activities of PAL, SOD, POD, PPO and CAT in groups with chitosan and Botrytis cinerea, and with chitosan, organosilicon, and Botrytis cinerea increased by 27.36%, 52.07%, 43.55%, 82.02% and 71.82%, and 18.91%, 30.22%, 57.14%, 38.09% and 53.64%, respectively. [Conclusion] Antioxidant enzyme activities of tomato seedlings could be improved by chitosan and organosilicon.
基金supported by National Natural Science Foundation of China(Grant No.11165012,Grant No. 11665012)the Project of the Natural Science Foundation of GanSu(145RJZA159)
文摘The deposition of organosilicone thin films from hexamethyldisiloxane（HMDSO） by using a dual-frequency （50 kHz/33 MHz） atmospheric-pressure micro-plasma jet with an admixture of a small volume of HMDSO and Ar was investigated.The topography was measured by using scanning electron microscopy.The chemical bond and composition of these films were analyzed by Fourier transform infrared spectroscopy （FTIR） and x-ray photoelectron spectroscopy.The results indicated that the as-deposited film was constituted by silicon,carbon,and oxygen elements,and FTIR suggested the films are organosilicon with the organic component （-CHx） and hydroxyl functional group（-OH） connected to the Si-O-Si backbone.Thin-film hardness was recorded by an MH-5-VM Digital Micro-Hardness Tester.Radio frequency power had a strong impact on film hardness and the hardness increased with increasing power.
文摘Based on determination for surface tension of organosilicone solution and its expansion on the solid surface, the biological activity of 5% emameetin ben- zoate WDG with organosilicone against beet armyworm was determined by spraying method to study their synergistic activity. The results showed that organosilicone significandy reduced surface tension of aqueous solution, and the surface tension was reduced to 26raN/m as the concentration of organosilicone was 0.01%. The organosilicone significantly raised expansion of liquid drops on solid surface, and the expansion diameter of 10 μL 0.01% organosilicone was 34 ram. The indoor toxicity results indicated that when addition dosage of organosilieone was 1% -5%, synergistic activity of 5% emamectin benzoate WDG with organosilicone against beet armyworm was significant, and increase extent of synergistic activity slowed down as organosilieone dosage was higher than 5%. Field experiment showed that the control efficacies of 5% emamectin benzoate WDG ＋5% organosilicone 33 mg/ L against beet armyworm were 81.57% and 82.66% after spraying for 3 and 7 d respectively, which were significandy better than treatments of 5% emamectin benzoate WDG 33 rag/L, 24% metaflumizone SC 96 mg/L, 5% chlorantranilip- role SC 33 mg/L, 20% tlubendiamide WDG 40 mg/L and 15% indoxacarb EC 43 mg/L.
文摘Immobilization of active molecules by attachment onto solid surfaces is a well-established practice in many processes and applications. Silica micro- and nano-particles are attractive candidates as support for active molecules as a result of a combination of desirable properties. The present study deals with grafting of a functional UV active molecule onto silica surfaces via hydrosilylation reactions using multivalent organosilicon spacers. Different types of organosilicon precursors based on dimethylsiloxysilanes containing multiple SiH groups were used as spacers between vinyl-modified silica surface and the benzotriazole UV-absorber (UVA). Firstly, the surface of silica was modified with vinyltrimetoxsisilane coupling agent. The UVA molecules were attached to the silica-vinyl by a two-step procedure involving hydrosilylation reaction. The successful grafting was confirmed by FTIR, TGA and UV-Vis characterization. More than fivefold increase in UVA loading was found for the MH30 multifunctional spacer, which contains approximately 75 SiH groups per molecule, when compared to a four-functional spacer. Furthermore a branched, bulky six-functional spacer is preferred over a linear spacer of the same functionality. UV activity of functionalized silica was studied by UV-Vis spectroscopy, indicating that the immobilization of UVA onto silica surface has not altered its UV absorbance properties.
基金supported by the National Natural Science Foundation of China(NSFC,Nos.22175195,22075311 and 21975278).
文摘Comprehensive Summary,Low dielectric(low-k)organosilicon polymers have received extensive interests from industry and academia due to good electrical insulation,high temperature resistance,flame retardancy and hydrophobicity.These attractive properties enable them to be utilized as low-k materials in fabrication of electronic devices in high-frequency communication technology.This review summarizes recent progress in developing low-k organosilicon polymers,including the synthetic methods and properties of different organosilicon polymers classified according to the chemical structures.It may provide some inspiration to design new low-k organosilicon polymers for application in the.
文摘In the realm of the synthesis of heat-integrated distillation configurations,the conventional approach for exploring more heat integration possibilities typically entails the splitting of a single column into a twocolumn configuration.However,this approach frequently necessitates tedious enumeration procedures,resulting in a considerable computational burden.To surmount this formidable challenge,the present study introduces an innovative remedy:The proposition of a superstructure that encompasses both single-column and multiple two-column configurations.Additionally,a simultaneous optimization algorithm is applied to optimize both the process parameters and heat integration structures of the twocolumn configurations.The effectiveness of this approach is demonstrated through a case study focusing on industrial organosilicon separation.The results underscore that the superstructure methodology not only substantially mitigates computational time compared to exhaustive enumeration but also furnishes solutions that exhibit comparable performance.
