Background The effect of microbial phytase on amino acid and energy digestibility is not consistent in pigs,which may be related to the phytase dosage or the adaptation length to the diet.Therefore,an experiment was c...Background The effect of microbial phytase on amino acid and energy digestibility is not consistent in pigs,which may be related to the phytase dosage or the adaptation length to the diet.Therefore,an experiment was conducted to test the hypotheses that increasing dietary phytase after an 18-day adaptation period:1)increases nutrient and energy digestibility;2)increases plasma P,plasma inositol,and bone ash of young pigs;and 3)demonstrates that maximum phytate degradation requires more phytase than maximum P digestibility.Results Data indicated that increasing inclusion of phytase[0,250,500,1,000,2,000,and 4,000 phytase units(FTU)/kg feed]in corn-soybean meal-based diets increased apparent ileal digestibility(AID)of Trp(quadratic;P<0.05),and of Lys and Thr(linear;P<0.05),and tended to increase AID of Met(linear;P<0.10).Increasing dietary phytase also increased AID and apparent total tract digestibility(ATTD)of Ca and P(quadratic;P<0.05)and increased ATTD of K and Na(linear;P<0.05),but phytase did not influence the ATTD of Mg or gross energy.Concentrations of plasma P and bone ash increased(quadratic;P<0.05),and plasma inositol also increased(linear;P<0.05)with increasing inclusion of phytase.Reduced concentrations of inositol phosphate(IP)6 and IP5(quadratic;P<0.05),reduced IP4 and IP3(linear;P<0.05),but increased inositol concentrations(linear;P<0.05)were observed in ileal digesta as dietary phytase increased.The ATTD of P was maximized if at least 1,200 FTU/kg were used,whereas more than 4,000 FTU/kg were needed to maximize inositol release.Conclusions Increasing dietary levels of phytase after an 18-day adaptation period increased phytate and IP ester degradation and inositol release in the small intestine.Consequently,increasing dietary phytase resulted in improved digestibility of Ca,P,K,Na,and the first 4 limiting amino acids,and in increased concentrations of bone ash and plasma P and inositol.In a corn-soybean meal diet,maximum inositol release requires approximately 3,200 FTU/kg more phytase than that required for maximum P digestibility.展开更多
Two experiments were conducted to investigate the effect of dietary supplementation with phytase transgenic corn (PTC) on growth performance,phosphorus (P) utilization and excretion in growing pigs.In Exp.1,180 pi...Two experiments were conducted to investigate the effect of dietary supplementation with phytase transgenic corn (PTC) on growth performance,phosphorus (P) utilization and excretion in growing pigs.In Exp.1,180 pigs (Large White × Landrace,BW=37.7 kg) were randomly allotted to 4 treatments with 5 replicates of 9 pigs each in order to evaluate the effect of PTC supplementation in low-P diets on growth performance.Four corn soybean meal-based diets consisted of a positive control (PC) diet,a diet containing 500 units (U) of exogenous phytase kg-1 (EP) on the basis of low-P (inorganic P reduced by 0.05% from PC diet) and the low-P+500 (PTC1) or 750 (PTC2) phytase U of PTC kg-1.In Exp.2,20 barrows (Large White×Landrace,BW=31 kg,4 treatments with 5 replicates of 1 pig each) were randomly selected to evaluate the effect of PTC in low-P diets on serum parameters and nutrient utilization.Diets in Exp.2 were similar to those in Exp.1 except that the EP group was replaced by a low-P diet without exogenous phytase supplementation as a negative control (NC) group.The results from Exp.1 showed that the average daily gain (ADG) in the PTC2 group was significantly higher (P〈0.05) than that in the EP group over all periods.On the other hand,the feed:gain (F:G) ratio of the EP group was significantly higher (P〈0.05) than that of the PTC2 group during 1-21 and 1-42 d,respectively.There were no differences in average daily feed intake (ADFI) among all treatments (P〉0.05).The results from Exp.2 showed that the concentration of serum Ca in the NC group was the highest (P〈0.05),while the concentration of serum P in the PTC2 group was the highest (P〈0.05) among all treatments.There was a significant decrease (P〈0.05) in the P apparent digestibility of the NC group compared with the other groups,and that of PTC2 group was the best.Furthermore,fecal P excretion was reduced (P〈0.05) from 1.80 g d-1 in the PC group to 1.28 g d-1 in the PTC2 group.In conclusion,dietary supplementation with PTC could reduce the application of inorganic P,decrease fecal P excretion,and improve the growth performance of growing pigs.展开更多
In 2 experiments, 48 weanling (initial BW: 13.5 ± 2.4 kg, Exp. 1) were used to determine effects of a novel bacterial 6-phytase and 24 growing pigs (initial BW: 36.2 ± 4.0 kg, Exp. 2) expressed in Aspe...In 2 experiments, 48 weanling (initial BW: 13.5 ± 2.4 kg, Exp. 1) were used to determine effects of a novel bacterial 6-phytase and 24 growing pigs (initial BW: 36.2 ± 4.0 kg, Exp. 2) expressed in Aspergillus oryzae on the apparent total tract digestibility (ATTD) of phosphorus and calcium in corn-soybean meal diets fed to weanling and growing pigs. In Exp. 1 and 2, pigs were randomly allotted to 6 dietary treatments using a randomized complete block design and a balanced 2 period changeover design, respectively. In both experiments, 6 diets were formulated. The positive control diet was a corn-soybean meal diet with added inorganic phosphorus (Exp. 1:0.42 and 0.86% standardized total tract digestible phosphorus and total calcium, respectively; Exp. 2:0.32 and 0.79% standardized total tract digestible phosphorus and total calcium, respectively). A negative control diet and 4 diets with the novel phytase (Ronozyme HiPhos, DSM Nutritional Products Inc., Parsippany, N J) added to the negative control diet at levels of 500, 1,000, 2,000, and 4,000 phytase units (FYT)/kg were also formulated. In Exp. 1, the ATTD of phosphorus was greater (P 〈 0.01) for the positive control diet (60.5%) than for the negative control diet (40.5%), but increased (linear and quadratic, P 〈 0.01) as phytase was added to the negative control diet (40.5% vs. 61.6%, 65.1%, 68.7%, and 68.0%). The breakpoint for the ATTD of phosphorus (68.4%) was reached at a phytase inclusion level of 1,016 FYT/kg. In Exp. 2, the ATTD of phosphorus was greater (P〈 0.01) for the positive control diet (59.4%) than for the negative control diet (39.8%) and increased (linear and quadratic, P〈 0.01) as phytase was added to the negative control diet (39.8% vs. 58.1%, 65.4%, 69.1%, and 72.8%). The breakpoint for the ATTD of phosphorus (69.1%) was reached at a phytase inclusion level of 801 FYT/kg. in conclusion, the novel bacterial 6-phytase improved the ATTD of phosphorus and calcium in both weanling and growing pigs. The optimum level of inclusion for this phytase is 800 to 1,000 FYT/kg of complete feed to maximize ATTD of phosphorus and calcium in weanling and growing pigs展开更多
An experiment was conducted to investigate the requirement of nonphytate phosphorus(nPP) and efficacy of a genetically engineered yeast phytase(PHY A) for Lingnan yellow broilers from 22-to 42-d-old age.A total of...An experiment was conducted to investigate the requirement of nonphytate phosphorus(nPP) and efficacy of a genetically engineered yeast phytase(PHY A) for Lingnan yellow broilers from 22-to 42-d-old age.A total of 1 320 1-d-old male chicks were randomly divided into 11 dietary treatment groups,which consisted of 4 replicate floor pens with 30 birds per pen.The control group(treatment 1) was fed with basal diet of nPP 0.08% without dicalcium phosphate or phytase supplementation.Dietary levels of nPP were 0.16,0.24,0.32,0.40,0.48,and 0.56%,respectively,for treatments 2 to 7,through addition of dicalcium phosphate(chemistry grade) to the basal diet.Diets of treatments 8 to 11 were supplemented with PHY A at 200,400 and 600 U kg-1,a commercial phytase product(PHY B) at 400 U kg-1 level,respectively.The birds in 0.32-0.56% nPP groups gained more than those of the other groups(P0.05).The nPP supplementation significantly improved feed intake(P0.05).The feed gain ratio was significantly decreased by 0.40% nPP diet compared to the control birds(P0.05).The level of 0.48% nPP was required for optimum tibia development.The additions of PHY A at 400 and 600 U kg-1 level and PHY B all significantly improved ADG(P0.05),ADFI(P0.05),and dry defatted tibia weight(P0.05).Similarly,the percentage of tibia ash was increased by 600 U kg-1 PHY A supplementation(P0.05).The requirement of nPP for maximal ADG and highest percentage tibia ash both was 0.40%.The phosphorus equivalency value of PHY A was estimated as 685 U kg-1 for male yellow broilers of 22-to 42-d-old age.展开更多
As a specific type of acid phosphatses, phytases play diverse roles in plants by catalazing the degradation of phytic acid and its derivatives. In this study, a rice phytase gene referred to OsPHY1 has been functional...As a specific type of acid phosphatses, phytases play diverse roles in plants by catalazing the degradation of phytic acid and its derivatives. In this study, a rice phytase gene referred to OsPHY1 has been functionally characterized. OsPHY1 contains a 1 620 bp of open reading frame, encoding a 539-aa polypeptide. A conserve domain metallophosphatase (MPP) (MPP_PAPs), generally harbored in phytase and purple acid phosphatases (PAP), was identified in OsPHY1 (residue 194-398). Phylogenetic analysis revealed that OsPHY1 shares high similarities with phytase genes and PAP-type genes that derived from diverse plant species. The OsPHY1 transcripts were detected to be abundant in germinating seeds, suggesting that this gene plays potential roles on degradation of seed phytic acid and its derivatives during the germination process. Biochemical analysis confirmed that OsPHY1 possesses strong catalytic activities on phytic acid-Na2, with optimal temperature of 57°C and suitable pH of 3.5. Based on transgene analysis, the putative role of OsPHY1 in plants on utilization of phytate was assessed. Under the condition that phytic acid-Na2 was used as sole P source, the OsPHY1-overexpressing tobacco plants behaved higher phytase activities, higher concentrations of Pi, more accumulative amount of total phosphorus, and much more improved growth traits than those of the control plants. Therefore, OsPHY1 is acted as an important component on degradation of the phytins during the seed germination process in rice. Also, OsPHY1 has a potential use on generation of elite crop germplasms with improved use efficiencies on phytate and its derivatives.展开更多
The developing trends of livestock production are efficiency availability of phytate phosphorus and abuse of antibiotics. safety and sustainability, which face two major challenges: low As a solution phytases and ant...The developing trends of livestock production are efficiency availability of phytate phosphorus and abuse of antibiotics. safety and sustainability, which face two major challenges: low As a solution phytases and antimicrobial peptides are applied as feed additives. However, phytases and antimicrobial peptides are susceptible to proteases, costly by fermentation and potential toxic to production hosts. We transformed an optimized phytase-lactoferricin fusion gene PhyLfdriven by an en- dosperm-specific promoter Gt13aP and Bar (bialaphos resistance) gene as a selection maker into rice. The Bar and PhyLf genes were integrated into the rice genome, stably inherited and expressed. Their phosphinothricin acetyl transferase (PAT) protein content oftransgenic plants with glufosinate resistance varied between 50.45-93.39 IJg g-l. Fusion protein expressed especially in the seeds of transgenic rice had a summit phytase activity at 32.30 U g-l, which increased by 61.71-fold com- pared to the control/check group (CK) and 7.54-fold compared to un-optimized transgenic plant. The highest inorganic phosphorus (Pi) content of the transgenic seeds reached 13.15 mg g-~, increased by 12.77-fold compared to that of CK. Preliminary antibacterial experiments showed that the enterokinase hydrolysate product of fusion protein could inhibit the growth of Escherichia coil DH5a. These results indicated that the protein PhyLf has the potential to increase availability of feed phytate phosphorus, improve consumer's immunity and reduce the use of antibiotics.展开更多
This study investigated the effects of fermentation product containing phytase (FPP) that was fermented using waste vinegar residue (WVR) as substrate from Aspergillusficuum NTG-23 on productive performance, egg q...This study investigated the effects of fermentation product containing phytase (FPP) that was fermented using waste vinegar residue (WVR) as substrate from Aspergillusficuum NTG-23 on productive performance, egg quality, and phosphorus apparent metabolism of laying hens. First, 375 22-wk-old Jinghong hens were allocated into 5 treatments (5 replicates of 15 hens each) in an 8-wk experiment for evaluating the parameters of productive performance, egg quality, serum, and tibia. Experimental diets contained 4% FPP and 96% corn-soybean diet. The levels of dicalciurn phosphate (DCP) were 1.34, 1.01, 0.67, 0.34 and 0%. Next, thirty 31-wk-old Jinghong hens were fed 5 types of diets for evaluating phosphorous apparent metabolism rate. Egg productive rate, egg weight, feed conversion ratio, Haugh unit, egg albumen height, serum calcium, tibia ash, tibia ash calcium and tibia breaking strength were not different significantly among 5 treatments. The significant difference of average daily feed intake was not appeared when the DCP content of corn-soybean-FPP diet was reduced to 0.67%; the eggshell hardness, eggshell thickness and serum phosphorus were not reduced significantly until the DCP content of corn-soybean-FPP diet was reduced to 0.34%. The yolk color was improved when the laying hens fed deficient DCP corn-soybean-FPP diet. A 22.14% reduction in excreta phosphorus was observed when the laying hens fed low phosphorus (0.67% DCP) corn-soybean-FPP diet. A 30% elevation of phosphorus apparent metabolism rate was obtained when the DCP content of corn-soybean-FPP diet was decreased from 1.34 to 1.01%. The reducing cost of layer diet was totalized about 120 CNY 1000 kg1 diet when the content of DCP was 0.67% in corn-soybean-FPP diet. These results indicated that FPP could be applied in laying hen as a potential, cost-effective and rational application of WVR.展开更多
A 31 week feeding trial was conducted to investigated the effects of dietary supplementation of microbial phytase and cellulase on performance,nutrients utilization and tibia quality of laying hens fed maize and soyb...A 31 week feeding trial was conducted to investigated the effects of dietary supplementation of microbial phytase and cellulase on performance,nutrients utilization and tibia quality of laying hens fed maize and soybean meal diets.192 18 week old Hisex layers were used in the trial A 2×2×2 factorial design was used in the experiment with three factors of two levels each:0 38% and 0 16% of dietary non phytate P(nP).0 and 300 U·kg -1 of phytase (Ph),and 0 and 0 10% of cellulase (Ce).The results showed that supplementation of 300 U·kg -1 phytase significantly improved utilization of dietary crude ash,CP,Ca,total P and copper (P<0 05),and improved tibia breaking strength (P<0 05).No effect of phytase on performance was observed.Addition of 0 10% cellulase decreased feed intake (P<0 05),increased utilization of CF (P<0 05) and Ca(P<0 01),and decreased total tibia ash weight (P<0 05).300 U·kg -1 phytase and 0 10% cellulase exhibited obvious positive interactions to enhance utilization of dietary phytic P and copper (P<0 05).0 16% nP did not reduce performance of the layers,but improved egg shell quality at 20 wks,increased utilization of dietary total P,phytic P and Copper (P<0 01),decreased utilization of dietary CP,increased tibia breaking strength and Ca,Mn contents of tibia(P<0 01)展开更多
In most of the cereal crop, phytic acid is the main storage form of phosphorus, which can decrease the bioavailability of phosphate. Transgenic expression of phytase is regarded as an efficient way to release phosphat...In most of the cereal crop, phytic acid is the main storage form of phosphorus, which can decrease the bioavailability of phosphate. Transgenic expression of phytase is regarded as an efficient way to release phosphate from phytate in transgenic plants. In this study, a plant expression vector, containing the recombinant phytase gene driven by the maize ubiquitin (Ubi) promoter was constructed and introduced into an elite rice variety via Agrobacterium-mediated transformation. During the experiment, a total of 15 independent transgenic rice lines were regenerated. The results of PCR and Southern blot indicated that the target gene was integrated into the genome of transgenic rice plants. Moreover, the RT-PCR analysis of total RNAs extracted from the immature seeds of several transgenic lines showed that the recombinant phytase gene could be normally expressed. The inorganic phosphorus content, both in the mature seeds and the leaf was significantly higher in the transgenic plants than in the untransformed wild type.展开更多
Myo-inositol phosphates (phytates) are important biological molecules produced largely by plants to store phosphorus. Phytate is very abundant in many different soils making up a large portion of all soil phosphorus. ...Myo-inositol phosphates (phytates) are important biological molecules produced largely by plants to store phosphorus. Phytate is very abundant in many different soils making up a large portion of all soil phosphorus. This review assesses current phytase science from the perspective of its substrate, phytate, by examining the intricate relationship between the phytate-hydrolyzing enzymes and phytate as their substrate. Specifically, we examine available data on phytate’s structural features, distribution in nature and functional roles. The role of phytases and their localization in soil and plant tissues are evaluated. We provide a summary of the current biotechnological advances in using industrial or recombinant phytases to improve plant growth and animal nutrition. The prospects of future discovery of novel phytases with improved biochemical properties and bioengineering of existing enzymes are also discussed. Two alternative but complementary directions to increase phosphorus bioavailability through the more efficient utilization of soil phytate are currently being developed. These approaches take advantage of microbial phytases secreted into rhizosphere either by phytase-producing microbes (biofertilizers) or by genetically engineered plants. More research on phytate metabolism in soils and plants is needed to promote environmentally friendly, more productive and sustainable agriculture.展开更多
Background:The reduction of crude protein levels in diets for broiler chickens may generate economic,environmental and flock welfare and health benefits;however,performance is usually compromised.Whole grain feeding a...Background:The reduction of crude protein levels in diets for broiler chickens may generate economic,environmental and flock welfare and health benefits;however,performance is usually compromised.Whole grain feeding and phytase may improve the utilization of reduced crude protein diets.Results:The effects of pre-pellet cracked maize(0,15%and 30%)and phytase(0,750 and 1500 FTU/kg)in isoenergetic maize-soy diets with three levels of crude protein(22%,19.5%and 17%)were evaluated via a BoxBehnken response surface design.Each of 13 dietary treatments were offered to 6 replicate cages(6 birds/cage)of male Ross 308 broiler chicks from 7 to 28 d post-hatch.Model prediction and response surface plots were generated from experimental data via polynomial regression in R and only significant coefficients were included and discussed in the predicted models.Weight gain,feed intake and FCR were all influenced by pre-pellet cracked maize,phytase and crude protein level,where crude protein level had the greatest influence.Consequently,the reduction from 22%to 17%dietary crude protein in non-supplemented diets reduced weight gain,feed intake,relative gizzard weight,relative gizzard content and relative pancreas weight but improved FCR.However,the inclusion of 30%cracked maize to 17%crude protein diets restored gizzard weight and 1500 FTU phytase inclusion to 17%crude protein diets increased relative gizzard contents and pancreas weights.Cracked maize and phytase inclusion in tandem to 17%crude protein diets increased weight gain,feed intake and FCR;however,this FCR was still more efficient than broilers offered the non-supplemented 22%crude protein diet.Broilers offered the prepellet cracked maize and phytase inclusions reduced AME in 22%crude protein diets but improved AME by 2.92 MJ(14.16 versus 11.24 MJ;P<0.001)in diets containing 17%crude protein.Ileal N digestibility was greater in broilers offered diets with 17%crude protein than those offered the 22%crude protein diet;irrespective of phytase and pre-pellet cracked maize.Conclusion:Pre-pellet cracked maize and phytase inclusions will improve the performance of broilers offered reduced crude protein diets.展开更多
The effects of nutrients and physical conditions on phytase production were investigated with a recently isolated strain of Aspergillus tubingensis SKA under solid state fermentation on wheat bran. The nutrient factor...The effects of nutrients and physical conditions on phytase production were investigated with a recently isolated strain of Aspergillus tubingensis SKA under solid state fermentation on wheat bran. The nutrient factors investigated included carbon source, nitrogen source, phosphate source and concentration, metal ions (salts) and the physical parameters investigated included inoculum size, pH, temperature and fermentation duration. Our investigations revealed that optimal productivity of phytase was achieved using wheat bran supplemented with: 1.5% glucose. 0.5% (NH4)2SO4, 0.1% sodium phytate. Additionally, optimal physical conditions were 1 × 105 spore/g substrate, initial pH of 5.0, temperature of fermentation 30°C and fermentation duration of 96 h. Overall, a 34% improvement in phytase activity was achieved by using the optimal conditions.展开更多
The objective of this study was to investigate the effects of phytase supplementation on growth performance, slaughter performance, growth of internal organs and small intestine, and serum biochemical indices of broil...The objective of this study was to investigate the effects of phytase supplementation on growth performance, slaughter performance, growth of internal organs and small intestine, and serum biochemical indices of broilers. A total of 360 1-day-old Ross 308 broilers were randomly divided into 4 groups with 3 replicates and 30 broilers per replicate (15 male, 15 female). The treatments were fed with basal diet supplemented with 0%, 0.01%, 0.02% and 0.03% phytase. The results showed that: 1) Phytase supplementation increased the body weight gain and the body weight of Ross 308 broilers (P serum calcium (Ca) consistency was 0.02%. According to the above analysis, the feasible supplementation of phytase (enzyme activity for 5000 u/g) in broiler dietary was 0.02%.展开更多
Lupin seeds and rapeseed meal(RSM)contain relatively high amounts of poorly digestible phytate.Phytase additive can help in the utilization of nutrients from the diet.The aim of this study was to determine total tract...Lupin seeds and rapeseed meal(RSM)contain relatively high amounts of poorly digestible phytate.Phytase additive can help in the utilization of nutrients from the diet.The aim of this study was to determine total tract digestibility coefficients of nutrients and performance results of finishing pigs fed diets containing yellow lupin or narrow-leafed lupin seeds and/or RSM with similar or increasing levels of phytase.Three experiments were conducted.In Experiment I the effect of RONOZYME®HiPhos(100 g/t)in diets containing narrow-leafed or yellow lupin seeds and RSM on production parameters of fatteners was analyzed.In Experiment II the effect of phytase RONOZYME®HiPhos(1,000 FTU/t)in similar diets was analyzed but calcium(Ca)and phosphorus(P)levels in diets were reduced.In Experiment III the effect of increasing levels of Quantum Bluephytase(0,5,000,10,000 and 15,000 FTU/t)in diets with yellow lupin seeds with reduced Ca and P level on total tract digestibility coefficients of selected nutrients and performance of pigs was analyzed.In none of the experiments the enzyme additives included in the diet affected pig performance(p>0.05).There were no significant differences(p>0.05)in apparent total tract digestibility coefficients of dry matter(DM)and crude protein(CP).The phytase additives significantly improved P and Ca digestibility coefficients(p<0.05)in comparison with the control diet,but this improvement was not linearly related with phytase dosage.By improving digestibility phytase allows to reduce mineral contents in diets,thus reducing the cost of pig nutrition.展开更多
The active site motif of proteins belonging to "Histidine Acid Phosphatase" (HAP) contains a hepta-peptide region, RHGXRXP. A close comparison among fungal and yeast HAPs revealed the fourth residue of the h...The active site motif of proteins belonging to "Histidine Acid Phosphatase" (HAP) contains a hepta-peptide region, RHGXRXP. A close comparison among fungal and yeast HAPs revealed the fourth residue of the hepta-peptide to be E instead of A, which is the case with A. niger PhyA phytase. However, another phytase, PhyB, from the same microorganism has a higher turnover number and it shows E in this position. We mutated A69 residue to E in the fungal PhyA phytase. The mutant phytase shows a myriad of new kinetic properties. The pH profile shifted 0.5 pH unit in both 5.0 and 2.5 bi-hump peaks. The optimum temperature shifted down from 58℃ to 55℃. However, the greatest difference was observed in the mutant protein's reaction to GuCl at a concentration of 0.1 to 0.2 M. The activity of the mutant phytase jumped 100% while the wild type protein showed no activity enhancement in the same concentration range of GuCl. The kinetics performed at higher concentration of GuCl also contrasted the difference between the wild type and mutant phytase. While Km was least affected, the Vmax increased for the mutant and decreased for the wild type. The sensitivity towards myo-inositol hexasulfate, a potent inhibitor, was decreased by the mutation. All in all, A69E mutation has affected a multitude of enzymatic properties of the protein even though the residue was thought to be non-critical for phytase's catalytic function notwithstanding its location in the conserved hepta-peptide region of the biocatalyst.展开更多
In this study, the optimum temperature was lowered while the residual phytase activity after heating to 70℃ was raised in a widely utilized phytase, Aspergillus niger NRRL 3135 PhyA. This was accomplished by site-dir...In this study, the optimum temperature was lowered while the residual phytase activity after heating to 70℃ was raised in a widely utilized phytase, Aspergillus niger NRRL 3135 PhyA. This was accomplished by site-directed mutagenesis of the cysteines that are involved in the formation of a single disulfide bridge (DB). When compared to wild type (WT), three of the four mutant phytases displayed a lower optimum temperature, 42℃, and up to a four-fold increase in activity after heating. These findings have a potentially broad application to be incorporated along with other desirable features to engineer a phytase with superior physical and chem-ical attributes for animal feed applications.展开更多
The ful length phytase gene of Mitsuokel a jalaludini was successful y cloned and was found to be 1 047 bp in length, with 348 amino acids, and was designated as PHY7 phytase gene. A comparison of the sequence of PHY7...The ful length phytase gene of Mitsuokel a jalaludini was successful y cloned and was found to be 1 047 bp in length, with 348 amino acids, and was designated as PHY7 phytase gene. A comparison of the sequence of PHY7 phytase gene of M. jalaludini with various microbial phytase gene sequences showed that it was not similar to those from other bacteria except Selenomonas ruminatium, thus suggesting that they may both express a new class of phytase. The PHY7 phytase gene was subsequently subcloned into bacterial expression vector, pET32a, for expression in Escherichia coli strain Ro-setta-gami. Expression of the recombinant phytase gene was optimised and characterised. The recombinant phytase was estimated to be approximately 55 kDa by SDS-PAGE analysis. The recombinant phytase exhibited optimum activity at 55°C, pH 4.5 and showed good pH stability from pH 3.5 to 5.5 (>78%relative activity). Metal ions such as Ca2+, Mg2+, and K+were found to exert signiifcant stimulatory effect on the recombinant phytase activity while Cu2+, Fe3+, and Zn2+greatly inhibited the enzyme activity. The recombinant phytase showed moderate resistance to trypsin proteolysis, but susceptible to pepsin proteolysis. The results of the study showed that several characteristics of recombinant phytase were slightly different from the native enzyme. Unfavourable characteristics such as reduced pH stability and metal ion effects should be taken into consideration during feed enzyme formulation.展开更多
In most of the raw materials of plant origin used in animal feed, a portion of the phosphorus is stored as phytic acid or phytate. Phytate is the main storage form of phosphorus in vegetables but is not readily assimi...In most of the raw materials of plant origin used in animal feed, a portion of the phosphorus is stored as phytic acid or phytate. Phytate is the main storage form of phosphorus in vegetables but is not readily assimilated into food at low concentrations of the enzyme phytase. In addition to making phosphorous unavailable, phytate binds divalent cations such as calcium, copper, magnesium, iron, manganese and zinc, preventing the absorption of these nutrients in the gut of the animal. Phytase promotes the hydrolysis of the phytate phosphorus-releasing molecule, thereby increasing its bioavailability in feed. Phytase is distributed in plant and animal tissues and it is synthesized by some species of bacteria and fungi. The addition of this enzyme in the diet of animals is essential to promote greater uptake of phosphorus and also contributes to a decrease in the levels of phosphorus excreted by animals, thus reducing the pollution caused by excess phosphorus in the environment. This work aimed to select a fungus that stands out in the production of phytase among 100 isolates from Brazilian caves belonging to the genera Aspergillus, Penicillium and Cladosporium and 13 endophytic fungi of the aerial part of the coffee plant. For selection, the fungi were cultured in medium containing phytic acid as a sole source of phosphorus. After seven days at 25 °C, we evaluated growth and enzyme production by the presence of the phytic acid halo degradation (Enzymatic Index-EI) surrounding the colonies. Forty-seven species produced phytase, and the fungi Penicillium minioluteum (CF279) and Muscodor sp. (UBSX) showed higher degradation halos, 2.41 and 4.46, respectively. Considering the Muscodor sp. as the main source of phytase, high enzymatic levels were obtained when the fungus was grown under submerged fermentation with initial pH of 5.0 using wheat bran as additional carbon source for 144 h, at 125 rpm and 30 °C. Additionally, the enzyme was stable at pH 5.0 and 40 °C, and inhibited (14% - 88%) by all compounds analyzed. Then, this is the first study that reports the production of phytase by the endophytic fungus Muscodor sp.展开更多
The objective of this study was to eval- uate the effects of inorganic phosphorus source and phytase addition on performance, nutrient digestibility and bone mineralization in broiler chickens. In Exp. 1,150 two-day o...The objective of this study was to eval- uate the effects of inorganic phosphorus source and phytase addition on performance, nutrient digestibility and bone mineralization in broiler chickens. In Exp. 1,150 two-day old, male broiler chicks were fed a corn-soybean meal basal diet supplemented with phos- phorus provided by dicalcium phosphate, tricalcium phosphate or defluorinated rock phosphate. Five cages containing 10 birds were allotted to each of the three treatments. In Exp. 2,120 three-day old, male broiler chicks were fed the basal diet from Exp. 1 supplemen- ted with 0,250,500 ,or 1,000 P-'rU phytase per kg of diet. Six cages containing five chicks were allotted to each of the four treatments. In Exp. 1, there was no difference in weight gain, feed intake or feed conver- sion as a result of feeding the different sources of in- organic phosphorus. The digestibility of phosphorus was significantly lower (P =0.01 ) for chicks fed di- ets supplemented with tricalcium phosphate than for chicks fed the other two diets. However, despite the lower digestibility, serum phosphorus levels did not differ among the three treatments. For Exp. 2, feedconversion showed a linear improvement (P = 0.03 ) with increasing levels of phytase inclusion ( days 0 to 33 ). Phytase supplementation resulted in linear increa- ses in the digestibility of dry matter (P = 0.02 ), crude protein ( P --- 0.04 ) and energy ( P 〈 0.01 ). Chicks fed 1,000 FTU/kg phytase had significantly higher bone calcium ( P = 0.05 ) and bone breaking strength (P = 0.04 ) than chicks fed the basal diet on day 33. In conclusion, the results of the current study indicated that the performance of birds fed diets sup- plemented with dicalcium phosphate, tricalcium phos- phate or defluorinated phosphate was similar and therefore production costs could be lowered by choo- sing the cheapest inorganic phosphorus source when formulating diets for poultry. When diets were formu- lated to meet dietary phosphorus requirements, the growth of broilers was not enhanced with phytase sup- plementation. However, increases in feed conversion and bone breaking strength and its potential to impact culling and mortality in broiler operations may be suf- ficient justification for the routine inclusion of phytase in diets fed to broilers.展开更多
A corn-soybean meal diet (CSB) (or Diet 1) containing 23% crude protein (CP) was used as the positive control, and another corn-soybean meal diet containing 21% CP and 15% wheat middlings (WM) (or Diet 2) wa...A corn-soybean meal diet (CSB) (or Diet 1) containing 23% crude protein (CP) was used as the positive control, and another corn-soybean meal diet containing 21% CP and 15% wheat middlings (WM) (or Diet 2) was used as the basal diet, which was treated with four different treatments. Digestibility experiment was employed to discuss the collective effect of citric acid, and intrinsic and microbial phytase. By comparing and analyzing effects of them in the low-nutrient broiler diets, the results showed five treatments had similar effects on Tibia ash (%) (mg) (P〉0.05). Under the supplementation of bacterial phytase or citric acid, the daily body weight gain (ADG), gain:feed (G:F) ratio, and calcium (Ca) utilization were similar to that of standard-nutrient CSB diet (Diet 1) (P 〉 0.05). And, fecal phosphorus (P) and CP utilization were lower than (P〈0.05) that of Diet 1. But P utilization was significantly higher than (P〈0.01) that of Diet 1. However, the ADG, G:F, and CP utilization produced by supplementation of intrinsic phytase were lower than those of Diet 1, but other aspects were similar to those produced by Diet 1 (P〉0.05). In Diet 5, citric acid, intrinsic and bacterial phytase were added to the diet, which produced a 1.4% decrease on fecal P, a 7.2% increase on Ca utilization, which was significantly higher than (P〈0.01) those of the other four Diets, a 3.9% increase on G:F, which was similar to that of Diet 1, and a 2.3% increase on CP utilization, which was higher than (P〈0.05) that of the other three diets. In summary, the results of this study indicated that citric acid, intrinsic and bacterial phytase might have some additive or synergistic effects, and low-nutrient CSB diets with 15% wheat middlings, 750 U kg^-1 phytase, and 3% citric acid might substitute completely for standard CSB in broilers.展开更多
基金support for this research from AB Vista,Marlborough,UK,is greatly appreciated。
文摘Background The effect of microbial phytase on amino acid and energy digestibility is not consistent in pigs,which may be related to the phytase dosage or the adaptation length to the diet.Therefore,an experiment was conducted to test the hypotheses that increasing dietary phytase after an 18-day adaptation period:1)increases nutrient and energy digestibility;2)increases plasma P,plasma inositol,and bone ash of young pigs;and 3)demonstrates that maximum phytate degradation requires more phytase than maximum P digestibility.Results Data indicated that increasing inclusion of phytase[0,250,500,1,000,2,000,and 4,000 phytase units(FTU)/kg feed]in corn-soybean meal-based diets increased apparent ileal digestibility(AID)of Trp(quadratic;P<0.05),and of Lys and Thr(linear;P<0.05),and tended to increase AID of Met(linear;P<0.10).Increasing dietary phytase also increased AID and apparent total tract digestibility(ATTD)of Ca and P(quadratic;P<0.05)and increased ATTD of K and Na(linear;P<0.05),but phytase did not influence the ATTD of Mg or gross energy.Concentrations of plasma P and bone ash increased(quadratic;P<0.05),and plasma inositol also increased(linear;P<0.05)with increasing inclusion of phytase.Reduced concentrations of inositol phosphate(IP)6 and IP5(quadratic;P<0.05),reduced IP4 and IP3(linear;P<0.05),but increased inositol concentrations(linear;P<0.05)were observed in ileal digesta as dietary phytase increased.The ATTD of P was maximized if at least 1,200 FTU/kg were used,whereas more than 4,000 FTU/kg were needed to maximize inositol release.Conclusions Increasing dietary levels of phytase after an 18-day adaptation period increased phytate and IP ester degradation and inositol release in the small intestine.Consequently,increasing dietary phytase resulted in improved digestibility of Ca,P,K,Na,and the first 4 limiting amino acids,and in increased concentrations of bone ash and plasma P and inositol.In a corn-soybean meal diet,maximum inositol release requires approximately 3,200 FTU/kg more phytase than that required for maximum P digestibility.
基金supported by the Key Program of Transgenic Plant Breeding,China (2008ZX08003-002)the Major Special Project of Guangdong Province,China(2009A080303009)+1 种基金the National Major Science Research Program of China (2009CB941601)the Special Fund for Agro-Scientific Research in the Public Interest,China (Agriculture,201003011)
文摘Two experiments were conducted to investigate the effect of dietary supplementation with phytase transgenic corn (PTC) on growth performance,phosphorus (P) utilization and excretion in growing pigs.In Exp.1,180 pigs (Large White × Landrace,BW=37.7 kg) were randomly allotted to 4 treatments with 5 replicates of 9 pigs each in order to evaluate the effect of PTC supplementation in low-P diets on growth performance.Four corn soybean meal-based diets consisted of a positive control (PC) diet,a diet containing 500 units (U) of exogenous phytase kg-1 (EP) on the basis of low-P (inorganic P reduced by 0.05% from PC diet) and the low-P+500 (PTC1) or 750 (PTC2) phytase U of PTC kg-1.In Exp.2,20 barrows (Large White×Landrace,BW=31 kg,4 treatments with 5 replicates of 1 pig each) were randomly selected to evaluate the effect of PTC in low-P diets on serum parameters and nutrient utilization.Diets in Exp.2 were similar to those in Exp.1 except that the EP group was replaced by a low-P diet without exogenous phytase supplementation as a negative control (NC) group.The results from Exp.1 showed that the average daily gain (ADG) in the PTC2 group was significantly higher (P〈0.05) than that in the EP group over all periods.On the other hand,the feed:gain (F:G) ratio of the EP group was significantly higher (P〈0.05) than that of the PTC2 group during 1-21 and 1-42 d,respectively.There were no differences in average daily feed intake (ADFI) among all treatments (P〉0.05).The results from Exp.2 showed that the concentration of serum Ca in the NC group was the highest (P〈0.05),while the concentration of serum P in the PTC2 group was the highest (P〈0.05) among all treatments.There was a significant decrease (P〈0.05) in the P apparent digestibility of the NC group compared with the other groups,and that of PTC2 group was the best.Furthermore,fecal P excretion was reduced (P〈0.05) from 1.80 g d-1 in the PC group to 1.28 g d-1 in the PTC2 group.In conclusion,dietary supplementation with PTC could reduce the application of inorganic P,decrease fecal P excretion,and improve the growth performance of growing pigs.
基金Financial support from DSM Nutritional Products,Parsippany,NJ,is appreciated
文摘In 2 experiments, 48 weanling (initial BW: 13.5 ± 2.4 kg, Exp. 1) were used to determine effects of a novel bacterial 6-phytase and 24 growing pigs (initial BW: 36.2 ± 4.0 kg, Exp. 2) expressed in Aspergillus oryzae on the apparent total tract digestibility (ATTD) of phosphorus and calcium in corn-soybean meal diets fed to weanling and growing pigs. In Exp. 1 and 2, pigs were randomly allotted to 6 dietary treatments using a randomized complete block design and a balanced 2 period changeover design, respectively. In both experiments, 6 diets were formulated. The positive control diet was a corn-soybean meal diet with added inorganic phosphorus (Exp. 1:0.42 and 0.86% standardized total tract digestible phosphorus and total calcium, respectively; Exp. 2:0.32 and 0.79% standardized total tract digestible phosphorus and total calcium, respectively). A negative control diet and 4 diets with the novel phytase (Ronozyme HiPhos, DSM Nutritional Products Inc., Parsippany, N J) added to the negative control diet at levels of 500, 1,000, 2,000, and 4,000 phytase units (FYT)/kg were also formulated. In Exp. 1, the ATTD of phosphorus was greater (P 〈 0.01) for the positive control diet (60.5%) than for the negative control diet (40.5%), but increased (linear and quadratic, P 〈 0.01) as phytase was added to the negative control diet (40.5% vs. 61.6%, 65.1%, 68.7%, and 68.0%). The breakpoint for the ATTD of phosphorus (68.4%) was reached at a phytase inclusion level of 1,016 FYT/kg. In Exp. 2, the ATTD of phosphorus was greater (P〈 0.01) for the positive control diet (59.4%) than for the negative control diet (39.8%) and increased (linear and quadratic, P〈 0.01) as phytase was added to the negative control diet (39.8% vs. 58.1%, 65.4%, 69.1%, and 72.8%). The breakpoint for the ATTD of phosphorus (69.1%) was reached at a phytase inclusion level of 801 FYT/kg. in conclusion, the novel bacterial 6-phytase improved the ATTD of phosphorus and calcium in both weanling and growing pigs. The optimum level of inclusion for this phytase is 800 to 1,000 FYT/kg of complete feed to maximize ATTD of phosphorus and calcium in weanling and growing pigs
基金supported by the the Earmarked Fund for Modern Agro-Industry Technology Research System,China (nycytx-42-G2-01)the grant from Ministry of Agriculture of China (nyhyzx07-038)
文摘An experiment was conducted to investigate the requirement of nonphytate phosphorus(nPP) and efficacy of a genetically engineered yeast phytase(PHY A) for Lingnan yellow broilers from 22-to 42-d-old age.A total of 1 320 1-d-old male chicks were randomly divided into 11 dietary treatment groups,which consisted of 4 replicate floor pens with 30 birds per pen.The control group(treatment 1) was fed with basal diet of nPP 0.08% without dicalcium phosphate or phytase supplementation.Dietary levels of nPP were 0.16,0.24,0.32,0.40,0.48,and 0.56%,respectively,for treatments 2 to 7,through addition of dicalcium phosphate(chemistry grade) to the basal diet.Diets of treatments 8 to 11 were supplemented with PHY A at 200,400 and 600 U kg-1,a commercial phytase product(PHY B) at 400 U kg-1 level,respectively.The birds in 0.32-0.56% nPP groups gained more than those of the other groups(P0.05).The nPP supplementation significantly improved feed intake(P0.05).The feed gain ratio was significantly decreased by 0.40% nPP diet compared to the control birds(P0.05).The level of 0.48% nPP was required for optimum tibia development.The additions of PHY A at 400 and 600 U kg-1 level and PHY B all significantly improved ADG(P0.05),ADFI(P0.05),and dry defatted tibia weight(P0.05).Similarly,the percentage of tibia ash was increased by 600 U kg-1 PHY A supplementation(P0.05).The requirement of nPP for maximal ADG and highest percentage tibia ash both was 0.40%.The phosphorus equivalency value of PHY A was estimated as 685 U kg-1 for male yellow broilers of 22-to 42-d-old age.
基金supported by the National Natural Science Foundation of China (30871466)and the Key Laboratory of Crop Growth Regulation of Hebei Province, China
文摘As a specific type of acid phosphatses, phytases play diverse roles in plants by catalazing the degradation of phytic acid and its derivatives. In this study, a rice phytase gene referred to OsPHY1 has been functionally characterized. OsPHY1 contains a 1 620 bp of open reading frame, encoding a 539-aa polypeptide. A conserve domain metallophosphatase (MPP) (MPP_PAPs), generally harbored in phytase and purple acid phosphatases (PAP), was identified in OsPHY1 (residue 194-398). Phylogenetic analysis revealed that OsPHY1 shares high similarities with phytase genes and PAP-type genes that derived from diverse plant species. The OsPHY1 transcripts were detected to be abundant in germinating seeds, suggesting that this gene plays potential roles on degradation of seed phytic acid and its derivatives during the germination process. Biochemical analysis confirmed that OsPHY1 possesses strong catalytic activities on phytic acid-Na2, with optimal temperature of 57°C and suitable pH of 3.5. Based on transgene analysis, the putative role of OsPHY1 in plants on utilization of phytate was assessed. Under the condition that phytic acid-Na2 was used as sole P source, the OsPHY1-overexpressing tobacco plants behaved higher phytase activities, higher concentrations of Pi, more accumulative amount of total phosphorus, and much more improved growth traits than those of the control plants. Therefore, OsPHY1 is acted as an important component on degradation of the phytins during the seed germination process in rice. Also, OsPHY1 has a potential use on generation of elite crop germplasms with improved use efficiencies on phytate and its derivatives.
基金funded by the National Programme on Research and Development of Transgenic Crops,China(2014ZX08001-003)the Open Research Fund of State Key Laboratory of Hybrid Rice,Hunan Hybrid Rice Research Center,China
文摘The developing trends of livestock production are efficiency availability of phytate phosphorus and abuse of antibiotics. safety and sustainability, which face two major challenges: low As a solution phytases and antimicrobial peptides are applied as feed additives. However, phytases and antimicrobial peptides are susceptible to proteases, costly by fermentation and potential toxic to production hosts. We transformed an optimized phytase-lactoferricin fusion gene PhyLfdriven by an en- dosperm-specific promoter Gt13aP and Bar (bialaphos resistance) gene as a selection maker into rice. The Bar and PhyLf genes were integrated into the rice genome, stably inherited and expressed. Their phosphinothricin acetyl transferase (PAT) protein content oftransgenic plants with glufosinate resistance varied between 50.45-93.39 IJg g-l. Fusion protein expressed especially in the seeds of transgenic rice had a summit phytase activity at 32.30 U g-l, which increased by 61.71-fold com- pared to the control/check group (CK) and 7.54-fold compared to un-optimized transgenic plant. The highest inorganic phosphorus (Pi) content of the transgenic seeds reached 13.15 mg g-~, increased by 12.77-fold compared to that of CK. Preliminary antibacterial experiments showed that the enterokinase hydrolysate product of fusion protein could inhibit the growth of Escherichia coil DH5a. These results indicated that the protein PhyLf has the potential to increase availability of feed phytate phosphorus, improve consumer's immunity and reduce the use of antibiotics.
基金supported financially by a grant of the National Key Technologies R&D Program of China during the 12th Five-Year Plan period(2011BAD26B01-2)the National System for Layer Production Technology of China(CARS-41-K16)
文摘This study investigated the effects of fermentation product containing phytase (FPP) that was fermented using waste vinegar residue (WVR) as substrate from Aspergillusficuum NTG-23 on productive performance, egg quality, and phosphorus apparent metabolism of laying hens. First, 375 22-wk-old Jinghong hens were allocated into 5 treatments (5 replicates of 15 hens each) in an 8-wk experiment for evaluating the parameters of productive performance, egg quality, serum, and tibia. Experimental diets contained 4% FPP and 96% corn-soybean diet. The levels of dicalciurn phosphate (DCP) were 1.34, 1.01, 0.67, 0.34 and 0%. Next, thirty 31-wk-old Jinghong hens were fed 5 types of diets for evaluating phosphorous apparent metabolism rate. Egg productive rate, egg weight, feed conversion ratio, Haugh unit, egg albumen height, serum calcium, tibia ash, tibia ash calcium and tibia breaking strength were not different significantly among 5 treatments. The significant difference of average daily feed intake was not appeared when the DCP content of corn-soybean-FPP diet was reduced to 0.67%; the eggshell hardness, eggshell thickness and serum phosphorus were not reduced significantly until the DCP content of corn-soybean-FPP diet was reduced to 0.34%. The yolk color was improved when the laying hens fed deficient DCP corn-soybean-FPP diet. A 22.14% reduction in excreta phosphorus was observed when the laying hens fed low phosphorus (0.67% DCP) corn-soybean-FPP diet. A 30% elevation of phosphorus apparent metabolism rate was obtained when the DCP content of corn-soybean-FPP diet was decreased from 1.34 to 1.01%. The reducing cost of layer diet was totalized about 120 CNY 1000 kg1 diet when the content of DCP was 0.67% in corn-soybean-FPP diet. These results indicated that FPP could be applied in laying hen as a potential, cost-effective and rational application of WVR.
文摘A 31 week feeding trial was conducted to investigated the effects of dietary supplementation of microbial phytase and cellulase on performance,nutrients utilization and tibia quality of laying hens fed maize and soybean meal diets.192 18 week old Hisex layers were used in the trial A 2×2×2 factorial design was used in the experiment with three factors of two levels each:0 38% and 0 16% of dietary non phytate P(nP).0 and 300 U·kg -1 of phytase (Ph),and 0 and 0 10% of cellulase (Ce).The results showed that supplementation of 300 U·kg -1 phytase significantly improved utilization of dietary crude ash,CP,Ca,total P and copper (P<0 05),and improved tibia breaking strength (P<0 05).No effect of phytase on performance was observed.Addition of 0 10% cellulase decreased feed intake (P<0 05),increased utilization of CF (P<0 05) and Ca(P<0 01),and decreased total tibia ash weight (P<0 05).300 U·kg -1 phytase and 0 10% cellulase exhibited obvious positive interactions to enhance utilization of dietary phytic P and copper (P<0 05).0 16% nP did not reduce performance of the layers,but improved egg shell quality at 20 wks,increased utilization of dietary total P,phytic P and Copper (P<0 01),decreased utilization of dietary CP,increased tibia breaking strength and Ca,Mn contents of tibia(P<0 01)
基金grants from Fok Ying Tuang Education Foundation of the Ministry of Education (No. 94019)National Natural Science Foundation of China (No. 30470992) the Government of Jiangsu Province (No. BK2003214).
文摘In most of the cereal crop, phytic acid is the main storage form of phosphorus, which can decrease the bioavailability of phosphate. Transgenic expression of phytase is regarded as an efficient way to release phosphate from phytate in transgenic plants. In this study, a plant expression vector, containing the recombinant phytase gene driven by the maize ubiquitin (Ubi) promoter was constructed and introduced into an elite rice variety via Agrobacterium-mediated transformation. During the experiment, a total of 15 independent transgenic rice lines were regenerated. The results of PCR and Southern blot indicated that the target gene was integrated into the genome of transgenic rice plants. Moreover, the RT-PCR analysis of total RNAs extracted from the immature seeds of several transgenic lines showed that the recombinant phytase gene could be normally expressed. The inorganic phosphorus content, both in the mature seeds and the leaf was significantly higher in the transgenic plants than in the untransformed wild type.
文摘Myo-inositol phosphates (phytates) are important biological molecules produced largely by plants to store phosphorus. Phytate is very abundant in many different soils making up a large portion of all soil phosphorus. This review assesses current phytase science from the perspective of its substrate, phytate, by examining the intricate relationship between the phytate-hydrolyzing enzymes and phytate as their substrate. Specifically, we examine available data on phytate’s structural features, distribution in nature and functional roles. The role of phytases and their localization in soil and plant tissues are evaluated. We provide a summary of the current biotechnological advances in using industrial or recombinant phytases to improve plant growth and animal nutrition. The prospects of future discovery of novel phytases with improved biochemical properties and bioengineering of existing enzymes are also discussed. Two alternative but complementary directions to increase phosphorus bioavailability through the more efficient utilization of soil phytate are currently being developed. These approaches take advantage of microbial phytases secreted into rhizosphere either by phytase-producing microbes (biofertilizers) or by genetically engineered plants. More research on phytate metabolism in soils and plants is needed to promote environmentally friendly, more productive and sustainable agriculture.
基金Financial support for this work was provided by Danisco Animal Nutrition.
文摘Background:The reduction of crude protein levels in diets for broiler chickens may generate economic,environmental and flock welfare and health benefits;however,performance is usually compromised.Whole grain feeding and phytase may improve the utilization of reduced crude protein diets.Results:The effects of pre-pellet cracked maize(0,15%and 30%)and phytase(0,750 and 1500 FTU/kg)in isoenergetic maize-soy diets with three levels of crude protein(22%,19.5%and 17%)were evaluated via a BoxBehnken response surface design.Each of 13 dietary treatments were offered to 6 replicate cages(6 birds/cage)of male Ross 308 broiler chicks from 7 to 28 d post-hatch.Model prediction and response surface plots were generated from experimental data via polynomial regression in R and only significant coefficients were included and discussed in the predicted models.Weight gain,feed intake and FCR were all influenced by pre-pellet cracked maize,phytase and crude protein level,where crude protein level had the greatest influence.Consequently,the reduction from 22%to 17%dietary crude protein in non-supplemented diets reduced weight gain,feed intake,relative gizzard weight,relative gizzard content and relative pancreas weight but improved FCR.However,the inclusion of 30%cracked maize to 17%crude protein diets restored gizzard weight and 1500 FTU phytase inclusion to 17%crude protein diets increased relative gizzard contents and pancreas weights.Cracked maize and phytase inclusion in tandem to 17%crude protein diets increased weight gain,feed intake and FCR;however,this FCR was still more efficient than broilers offered the non-supplemented 22%crude protein diet.Broilers offered the prepellet cracked maize and phytase inclusions reduced AME in 22%crude protein diets but improved AME by 2.92 MJ(14.16 versus 11.24 MJ;P<0.001)in diets containing 17%crude protein.Ileal N digestibility was greater in broilers offered diets with 17%crude protein than those offered the 22%crude protein diet;irrespective of phytase and pre-pellet cracked maize.Conclusion:Pre-pellet cracked maize and phytase inclusions will improve the performance of broilers offered reduced crude protein diets.
文摘The effects of nutrients and physical conditions on phytase production were investigated with a recently isolated strain of Aspergillus tubingensis SKA under solid state fermentation on wheat bran. The nutrient factors investigated included carbon source, nitrogen source, phosphate source and concentration, metal ions (salts) and the physical parameters investigated included inoculum size, pH, temperature and fermentation duration. Our investigations revealed that optimal productivity of phytase was achieved using wheat bran supplemented with: 1.5% glucose. 0.5% (NH4)2SO4, 0.1% sodium phytate. Additionally, optimal physical conditions were 1 × 105 spore/g substrate, initial pH of 5.0, temperature of fermentation 30°C and fermentation duration of 96 h. Overall, a 34% improvement in phytase activity was achieved by using the optimal conditions.
文摘The objective of this study was to investigate the effects of phytase supplementation on growth performance, slaughter performance, growth of internal organs and small intestine, and serum biochemical indices of broilers. A total of 360 1-day-old Ross 308 broilers were randomly divided into 4 groups with 3 replicates and 30 broilers per replicate (15 male, 15 female). The treatments were fed with basal diet supplemented with 0%, 0.01%, 0.02% and 0.03% phytase. The results showed that: 1) Phytase supplementation increased the body weight gain and the body weight of Ross 308 broilers (P serum calcium (Ca) consistency was 0.02%. According to the above analysis, the feasible supplementation of phytase (enzyme activity for 5000 u/g) in broiler dietary was 0.02%.
基金This study was supported by the programme“Improvement of Native Plant Protein Feeds,Their Production,Trade Turnover and Utilization in Animal Feed”of the Ministry of Agriculture and Rural Development of Poland(No.505.037.07)a subsidy from the Ministry of Science and Higher Education of Poland(No.506.533.04).
文摘Lupin seeds and rapeseed meal(RSM)contain relatively high amounts of poorly digestible phytate.Phytase additive can help in the utilization of nutrients from the diet.The aim of this study was to determine total tract digestibility coefficients of nutrients and performance results of finishing pigs fed diets containing yellow lupin or narrow-leafed lupin seeds and/or RSM with similar or increasing levels of phytase.Three experiments were conducted.In Experiment I the effect of RONOZYME®HiPhos(100 g/t)in diets containing narrow-leafed or yellow lupin seeds and RSM on production parameters of fatteners was analyzed.In Experiment II the effect of phytase RONOZYME®HiPhos(1,000 FTU/t)in similar diets was analyzed but calcium(Ca)and phosphorus(P)levels in diets were reduced.In Experiment III the effect of increasing levels of Quantum Bluephytase(0,5,000,10,000 and 15,000 FTU/t)in diets with yellow lupin seeds with reduced Ca and P level on total tract digestibility coefficients of selected nutrients and performance of pigs was analyzed.In none of the experiments the enzyme additives included in the diet affected pig performance(p>0.05).There were no significant differences(p>0.05)in apparent total tract digestibility coefficients of dry matter(DM)and crude protein(CP).The phytase additives significantly improved P and Ca digestibility coefficients(p<0.05)in comparison with the control diet,but this improvement was not linearly related with phytase dosage.By improving digestibility phytase allows to reduce mineral contents in diets,thus reducing the cost of pig nutrition.
文摘The active site motif of proteins belonging to "Histidine Acid Phosphatase" (HAP) contains a hepta-peptide region, RHGXRXP. A close comparison among fungal and yeast HAPs revealed the fourth residue of the hepta-peptide to be E instead of A, which is the case with A. niger PhyA phytase. However, another phytase, PhyB, from the same microorganism has a higher turnover number and it shows E in this position. We mutated A69 residue to E in the fungal PhyA phytase. The mutant phytase shows a myriad of new kinetic properties. The pH profile shifted 0.5 pH unit in both 5.0 and 2.5 bi-hump peaks. The optimum temperature shifted down from 58℃ to 55℃. However, the greatest difference was observed in the mutant protein's reaction to GuCl at a concentration of 0.1 to 0.2 M. The activity of the mutant phytase jumped 100% while the wild type protein showed no activity enhancement in the same concentration range of GuCl. The kinetics performed at higher concentration of GuCl also contrasted the difference between the wild type and mutant phytase. While Km was least affected, the Vmax increased for the mutant and decreased for the wild type. The sensitivity towards myo-inositol hexasulfate, a potent inhibitor, was decreased by the mutation. All in all, A69E mutation has affected a multitude of enzymatic properties of the protein even though the residue was thought to be non-critical for phytase's catalytic function notwithstanding its location in the conserved hepta-peptide region of the biocatalyst.
文摘In this study, the optimum temperature was lowered while the residual phytase activity after heating to 70℃ was raised in a widely utilized phytase, Aspergillus niger NRRL 3135 PhyA. This was accomplished by site-directed mutagenesis of the cysteines that are involved in the formation of a single disulfide bridge (DB). When compared to wild type (WT), three of the four mutant phytases displayed a lower optimum temperature, 42℃, and up to a four-fold increase in activity after heating. These findings have a potentially broad application to be incorporated along with other desirable features to engineer a phytase with superior physical and chem-ical attributes for animal feed applications.
基金The financial support provided by the Universiti Putra Malaysia under the Research University Grant Scheme and Ministry of Higher Education under the Long Term Research Grant Scheme, Malaysia
文摘The ful length phytase gene of Mitsuokel a jalaludini was successful y cloned and was found to be 1 047 bp in length, with 348 amino acids, and was designated as PHY7 phytase gene. A comparison of the sequence of PHY7 phytase gene of M. jalaludini with various microbial phytase gene sequences showed that it was not similar to those from other bacteria except Selenomonas ruminatium, thus suggesting that they may both express a new class of phytase. The PHY7 phytase gene was subsequently subcloned into bacterial expression vector, pET32a, for expression in Escherichia coli strain Ro-setta-gami. Expression of the recombinant phytase gene was optimised and characterised. The recombinant phytase was estimated to be approximately 55 kDa by SDS-PAGE analysis. The recombinant phytase exhibited optimum activity at 55°C, pH 4.5 and showed good pH stability from pH 3.5 to 5.5 (>78%relative activity). Metal ions such as Ca2+, Mg2+, and K+were found to exert signiifcant stimulatory effect on the recombinant phytase activity while Cu2+, Fe3+, and Zn2+greatly inhibited the enzyme activity. The recombinant phytase showed moderate resistance to trypsin proteolysis, but susceptible to pepsin proteolysis. The results of the study showed that several characteristics of recombinant phytase were slightly different from the native enzyme. Unfavourable characteristics such as reduced pH stability and metal ion effects should be taken into consideration during feed enzyme formulation.
文摘In most of the raw materials of plant origin used in animal feed, a portion of the phosphorus is stored as phytic acid or phytate. Phytate is the main storage form of phosphorus in vegetables but is not readily assimilated into food at low concentrations of the enzyme phytase. In addition to making phosphorous unavailable, phytate binds divalent cations such as calcium, copper, magnesium, iron, manganese and zinc, preventing the absorption of these nutrients in the gut of the animal. Phytase promotes the hydrolysis of the phytate phosphorus-releasing molecule, thereby increasing its bioavailability in feed. Phytase is distributed in plant and animal tissues and it is synthesized by some species of bacteria and fungi. The addition of this enzyme in the diet of animals is essential to promote greater uptake of phosphorus and also contributes to a decrease in the levels of phosphorus excreted by animals, thus reducing the pollution caused by excess phosphorus in the environment. This work aimed to select a fungus that stands out in the production of phytase among 100 isolates from Brazilian caves belonging to the genera Aspergillus, Penicillium and Cladosporium and 13 endophytic fungi of the aerial part of the coffee plant. For selection, the fungi were cultured in medium containing phytic acid as a sole source of phosphorus. After seven days at 25 °C, we evaluated growth and enzyme production by the presence of the phytic acid halo degradation (Enzymatic Index-EI) surrounding the colonies. Forty-seven species produced phytase, and the fungi Penicillium minioluteum (CF279) and Muscodor sp. (UBSX) showed higher degradation halos, 2.41 and 4.46, respectively. Considering the Muscodor sp. as the main source of phytase, high enzymatic levels were obtained when the fungus was grown under submerged fermentation with initial pH of 5.0 using wheat bran as additional carbon source for 144 h, at 125 rpm and 30 °C. Additionally, the enzyme was stable at pH 5.0 and 40 °C, and inhibited (14% - 88%) by all compounds analyzed. Then, this is the first study that reports the production of phytase by the endophytic fungus Muscodor sp.
文摘The objective of this study was to eval- uate the effects of inorganic phosphorus source and phytase addition on performance, nutrient digestibility and bone mineralization in broiler chickens. In Exp. 1,150 two-day old, male broiler chicks were fed a corn-soybean meal basal diet supplemented with phos- phorus provided by dicalcium phosphate, tricalcium phosphate or defluorinated rock phosphate. Five cages containing 10 birds were allotted to each of the three treatments. In Exp. 2,120 three-day old, male broiler chicks were fed the basal diet from Exp. 1 supplemen- ted with 0,250,500 ,or 1,000 P-'rU phytase per kg of diet. Six cages containing five chicks were allotted to each of the four treatments. In Exp. 1, there was no difference in weight gain, feed intake or feed conver- sion as a result of feeding the different sources of in- organic phosphorus. The digestibility of phosphorus was significantly lower (P =0.01 ) for chicks fed di- ets supplemented with tricalcium phosphate than for chicks fed the other two diets. However, despite the lower digestibility, serum phosphorus levels did not differ among the three treatments. For Exp. 2, feedconversion showed a linear improvement (P = 0.03 ) with increasing levels of phytase inclusion ( days 0 to 33 ). Phytase supplementation resulted in linear increa- ses in the digestibility of dry matter (P = 0.02 ), crude protein ( P --- 0.04 ) and energy ( P 〈 0.01 ). Chicks fed 1,000 FTU/kg phytase had significantly higher bone calcium ( P = 0.05 ) and bone breaking strength (P = 0.04 ) than chicks fed the basal diet on day 33. In conclusion, the results of the current study indicated that the performance of birds fed diets sup- plemented with dicalcium phosphate, tricalcium phos- phate or defluorinated phosphate was similar and therefore production costs could be lowered by choo- sing the cheapest inorganic phosphorus source when formulating diets for poultry. When diets were formu- lated to meet dietary phosphorus requirements, the growth of broilers was not enhanced with phytase sup- plementation. However, increases in feed conversion and bone breaking strength and its potential to impact culling and mortality in broiler operations may be suf- ficient justification for the routine inclusion of phytase in diets fed to broilers.
基金Shihezi University Natural Science Foundation, China (ZDGG200502).
文摘A corn-soybean meal diet (CSB) (or Diet 1) containing 23% crude protein (CP) was used as the positive control, and another corn-soybean meal diet containing 21% CP and 15% wheat middlings (WM) (or Diet 2) was used as the basal diet, which was treated with four different treatments. Digestibility experiment was employed to discuss the collective effect of citric acid, and intrinsic and microbial phytase. By comparing and analyzing effects of them in the low-nutrient broiler diets, the results showed five treatments had similar effects on Tibia ash (%) (mg) (P〉0.05). Under the supplementation of bacterial phytase or citric acid, the daily body weight gain (ADG), gain:feed (G:F) ratio, and calcium (Ca) utilization were similar to that of standard-nutrient CSB diet (Diet 1) (P 〉 0.05). And, fecal phosphorus (P) and CP utilization were lower than (P〈0.05) that of Diet 1. But P utilization was significantly higher than (P〈0.01) that of Diet 1. However, the ADG, G:F, and CP utilization produced by supplementation of intrinsic phytase were lower than those of Diet 1, but other aspects were similar to those produced by Diet 1 (P〉0.05). In Diet 5, citric acid, intrinsic and bacterial phytase were added to the diet, which produced a 1.4% decrease on fecal P, a 7.2% increase on Ca utilization, which was significantly higher than (P〈0.01) those of the other four Diets, a 3.9% increase on G:F, which was similar to that of Diet 1, and a 2.3% increase on CP utilization, which was higher than (P〈0.05) that of the other three diets. In summary, the results of this study indicated that citric acid, intrinsic and bacterial phytase might have some additive or synergistic effects, and low-nutrient CSB diets with 15% wheat middlings, 750 U kg^-1 phytase, and 3% citric acid might substitute completely for standard CSB in broilers.