Effect of ionic strength and mixing ratio on complex coacervation of soy protein isolate/Flammulina velutipes polysaccharide

Soy protein isolate(SPI)is a commercial protein with balanced amino acids,while the poor solubility impedes its use in traditional foods.To overcome the problem,the complex coacervation of SPI/Flammulina velutipes polysaccharide(FVP)were investigated.Initial results revealed that the suitable amounts of FVP contributed to reducing the turbidity of SPI solution.Under electrostatic interaction,the formation of SPI/FVP coacervates were spontaneous and went through a nucleation and growth process.Low salt concentration(C_(NaCl)=10,50 mmol/L)led to an increase in the critical pH values(pHc,pHφ1)while the critical pH values decreased when C_(NaCl)≥100 mmol/L.The concentration of NaCl ions increased the content ofα-helix.With the increase of FVP,the critical pH values decreased and the content ofβ-sheet increased through electrostatic interaction.At SPI/FVP ratio of 10:1 and 15:1,the complex coacervation of SPI/FVP were saturated,and the coacervates had the same storage modulus value.SPI/FVP coacervates exhibited solid-like properties and presented the strongest storage modulus at C_(NaCl)=50 mmol/L.The optimal pH,SPI/FVP ratio and NaCl concentration of complex coacervation were collected,and the coacervates demonstrated a valuable application potential to protect and deliver bioactives and food ingredients.

Drying kinetics of soy protein isolate-corn starch film during preparation and its moisture adsorption characteristics during storage

To better understand the mass transfer process of moisture in the soy protein isolate-corn starch(SPI-CS)films during preparation and storage process,the drying kinetics model of SPI-CS films with different formation conditions during the drying process and the moisture adsorption characteristics of the SPI-CS films under different humidity conditions were investigated.Within the range of experimental conditions,the moisture migration rule in the SPI-CS films during the drying preparation was combined with the Page model which was expressed as MR=exp(-kt^(n)).It was found that the adsorption equilibrium needed shorter time(about 3 h)when the SPI-CS films existed in the environment with lower humidity(RH<54%).Additionally,the secondorder adsorption kinetic equation was successful to describe the moisture adsorption characteristic of the SPICS films during storage under different humidity conditions.

PREPARATION AND CHARACTERIZATION OF SOY PROTEIN ISOLATE(SPI)/MONTMORILLONITE(MMT) BIONANOCOMPOSITES

The bionanocomposites of soy protein isolate(SPI)/montmorillonite(MMT) have been prepared successfully via simple melt mixing,in which MMT was used as nanofiller and glycerol was used as plasticizer.Their structures and properties were characterized with X-ray diffraction(XRD),differential scanning calorimetry(DSC),scanning electron microscopy(SEM),thermogravimetric analysis and tensile testing.XRD、TEM and SEM results indicated that the MMT layers could be easily intercalated by the SPI matrix even by simpl...

Soy Protein Isolate Non-Isocyanates Polyurethanes(NIPU)Wood Adhesives

Soy-protein isolate(SPI)was used to prepare non-isocyanate polyurethane(NIPU)thermosetting adhesives for wood panels by reacting it with dimethyl carbonate(DMC)and hexamethylene diamine.Both linear as well as branched oligomers were obtained and identified,indicating how such oligomer structures could further cross-link to form a hardened network.Unusual structures were observed,namely carbamic acid-derived urethane linkages coupled with lactam structures.The curing of the adhesive was followed by thermomechanical analysis(TMA).It appeared to follow a two stages process:First,at a lower temperature(maximum 130℃),the growth of linear oligomers occurred,finally forming a physically entangled network.This appeared to collapse and disentangle,causing a decrease of MOE,as the temperature increases.This appears to be due to the ever more marked Brownian movements of the linear oligomer chains with the increase of the temperature.Second,chemical cross-linking of the chains appeared to ensue,forming a hardened network.This was shown by the thermomechanical analysis(TMA)showing two distinct MOE maxima peaks,one around 130℃ and the other around 220℃,with a very marked MOE decrease between the two.Plywood panels were prepared and bonded with the SPI-NIPU wood adhesive and the results obtained are presented.The adhesive appeared to pass comfortably the requirements for dry strength of relevant standards,showing to be suitable for interior grade plywood panels.It did not pass the requirements for wet tests.However,addition of 15%of glycerol diglycidyl ether improved the wet tests results but still not enough to satisfy the standards requirements.

Soy Protein Isolate Film by Incorporating Mandelic Acid as Well as Through Fermentation Mediated by Bacillus Subtilis

Soy protein isolate(SPI)biopolymeric films were prepared by adding different contents of mandelic acid(1 to 5%wrt SPI)to glycerol plasticized SPI by solution casting method.Also,SPI was fermented by Bacillus subtilis to get fermented SPI films by solution casting.Molecular mass determination of mandelic acid incorporated and fermented SPI films was carried out by sodium dodecyl sulphate-polyacrylamide gel electrophoresis(SDS-PAGE).Mandelic acid incorporated and fermented SPI films were characterized by Fourier-transform infrared spectroscopy(FT-IR),dynamic mechanical analysis(DMA),tensile strength,water uptake and optical transmittance studies.Results indicated that incorporation of mandelic acid in SPI resulted in high tensile strength(8.03 MPa)and highα-relaxation(Tα)as well as low water uptake.On the other hand,films cannot be prepared from fermented SPI with SPI contents of 8%and 12%.However,film from fermented SPI with 16%SPI content could be prepared but it exhibited low tensile strength(3.18 MPa)and low Tαas well as high water uptake.The resulting mandelic acid incorporated SPI films were also subjected to antimicrobial studies.At all the concentration of mandelic acid,we can easily observe the antimicrobial effect in mandelic acid incorporated SPI films unlike fermented SPI films.This work will be helpful in fabricating antimicrobial SPI film from renewable resources.

ZnSe Nanoparticles Reinforced Biopolymeric Soy Protein Isolate Film

ZnSe nanoparticles have been synthesized by microwave assisted method by using zinc chloride,selenium powder and ethylene diamine.The synthesized nanoparticles have been characterized structurally by FT-IR and XRD as well as morphological characterization was done by scanning electron microscope(SEM).The crystallite size after synthesis was obtained around 30 nm for pure ZnSe nanocrystallites.However,from SEM micrograph,agglomerated ZnSe nanoparticles of irregular shapes were observed.The as-synthesized ZnSe nanoparticles at different contents(1 to 5%w/w w.r.t SPI)were incorporated into soy protein isolate(SPI)to produce reinforced SPI films by solution casting method.The ZnSe nanoparticles incorporated SPI suspensions were subjected to molecular mass and specific conductivity studies.Neat and ZnSe nanoparticles incorporated SPI films were structurally and mechanically characterized by FT-IR and tensile properties,respectively.Transmittance and water uptake studies were also carried out for ZnSe nanoparticles incorporated SPI films.The tensile strength and modulus increased from 5.80 MPa to 10.06 MPa and 18.84 MPa to 94.70 MPa with the increase in the contents of ZnSe nanoparticles from 0 to 5%.Moreover,the results also revealed a good antibacterial effect in ZnSe nanoparticles incorporated SPI film.The main application of nanoparticles incorporated SPI film will be in the area of biodegradable packaging.

Completely Green Synthesis of Ag Nanoparticles Stabilized by Soy Protein Isolate under UV Irradiation

A completely green pathway for the preparation of Ag nanoparticles was proposed, by using soy protein isolate （SPI） as stabilizer under UV irradiation and H2O as the environmentally benign solvent throughout the preparation. Transmission electronic microscopy （TEM） and zeta potential characterization results indicated that the Ag nanoparticles were stable and well dispersed with an average diameter about 13 nm, and X-ray diffraction （XRD） analysis of SPI/Ag composite nanoparticles confirmed the formation of metallic silver. UV-Vis spectrum showed that the Ag nanoparticles dispersion solution had the maximum absorbance at about 430 nm due to surface plasmon resonance of the Ag nanoparticles. Infrared spectroscopy confirmed that the polypeptide backbone of SPI was not cleaved during the conjugation process and that some active amino groups were oxidized. The SPI/Ag composite nanoparticles have excellent antibacterial activity against two representative bacteria, staphylococcus aureus （Gram positive） and escherichia coli （Gram negative） in the presence of SPI.

Rheological Properties of Soy Protein Isolate and Polyurethane in the PAN/DMSO Solution

The rheological properties of soy protein isolate (SPI) and polyurethane (PU) in the PAN/DMSO solution were investigated in this study. The results showed that all these solutions possessed pseudo-plastic solution properties. There are opposite effects of SPI and PU in the PAN/DMSO solution. Their apparent viscosity, degree of non-Newtonian fluid, and extent of structuralization of blend system increase with the addition of SPI, whereas, all of these decrease with the addition of PU. Moreover, the rheological properties of PAN/DMSO solution were affected when SPI and PU were added equally, and SPI presented more effect when the proportion of ingredient was less, and PU presented more effect when the proportion of ingredient was more.

Study on the Hydrogen Bond Interaction Between Soy Protein Isolate and Glycerol Using Two-Dimensional Correlation Fourier-Transform Infrared Spectroscopy

A series of soy protein isolate(SPI)films plasticized by glycerol(Gly)were studied using attenuated total reflectance-Fourier transform infrared spectroscopy(ATR/FTIR).Perturbation-correlation movingwindow two-dimensional(PCMW2D)and two-dimensional correlation(2DCOS)analyses were applied to the amideⅠband and thus the hydrogen bond interaction between SPI and Gly was systematically investigated.When Gly concentrations were in the range 0~35%,the hydrogen bond amongβ-sheets was replaced by the one between SPI chain and Gly molecule,which caused these protein chains being changed toα-helix.However,the transformation ofβ-sheet toα-helix was saturated and both of them tend to change to random coil when Gly concentrations were in the range 35%~60%.

Effect of Pressurized Soy Protein Isolate upon the Growth and Antioxidants Functions of SD Rat

The objective of this study is to specify the effect of pressurized soy protein isolate (pSPI), upon the physical development, growth hormones and antioxidants functions of SD rats. The methodology depends on the selection of one hundred male SD rats, divided randomly into 5 groups. Each group consists of 20 rats. The groups will be defined as one blank control group, three groups with pSPI at low, medium and high doses and another control group with native soy protein isolates (nSPI). Low, medium and high doses are represented by 0.333 g/kg, 1.667 g/kg and 3.333 g/kg pSPI per weight, respectively. The native soy protein isolate is represented by 3.333 g/kg nSPI per weight. In every group, four animals will be taken out to collect the blood samples and analyze insulin like growth factor-I, growth hormone, thyroid stimulating hormone, thyroxine and triiodothyronin. The other SD rats will be subjected to feeding for 63 consecutive days. The body weight, the body length and food intake of each rat are measured. The total antioxidant capacity, superoxide dismutase (SOD), malondialdehyde and Glutathione Peroxidase in liver and serum of each rat will be analyzed. The results indicated that the groups with medium and high dose of pSPI result in an obvious increase in the body weight, body length and food utilization rate of SD rats. Also, pSPI has a great effect on the growth and antioxidants functions of SD rat.

Isolated Soy Protein-Based Diet Ameliorates Glycemia and Antioxidants Enzyme Activities in Streptozotocin-Induced Diabetes

The objective of this study was to evaluate the changes induced by isolated soy protein (ISP)-based diet on glycemia and oxidative stress biomarkers in diabetic rats. Fifteen male Wistar rats (35 ± 4 g, aged 21 days) were assigned to three groups: Casein (C group), which received casein-based diet during experimental protocol;Diabetic treated with Casein (D + C group) that received casein-based diet before and after diabetes induction;Diabetic treated with ISP (D + S group) that received casein-based diet before diabetes induction and after received ISP-based diet for the experimental protocol. Diabetes was induced by a single dose of streptozotocin (50 mg/kg body weight i.v.). After three weeks of dietary treatment, total nitrates, lipid peroxidation, antioxidant enzyme activities of superoxide dismutase (SOD), catalase (CAT), glutathione-S-transferase (GST) were measured in heart homogenates. ISP-based diet promoted an improvement in the glycemic levels of diabetic rats compared with casein-based diet (362 ± 25 vs 461 ± 30 mg/dL). CAT activity demonstrated a significant decrease in D + C and D + S groups. D + S group presented a significant increase in SOD and GST activities. Lipid peroxidation was not different among experimental groups. The overall results suggested the potential benefits of ISP-based diet consumption to improve the life quality of diabetic patients.

基于挤压技术的SPI添加对大米粉及米面条品质探究

本实验采用外源蛋白添加和挤压相结合的技术通过增强混合体系内部的凝胶结构来改善大米粉面条弹韧性差、断条严重等问题。向大米粉中添加大豆分离蛋白(Soybean Protein Isolate,SPI)并经过挤压膨化处理制备混合米粉,选择SPI添加量、水分含量和挤压温度3个因素,以糊化特性和吸水性指数为指标优化混合米粉的最佳工艺,并对米面条的品质进行评价。各因素对混合米粉制备工艺的影响顺序:SPI添加量>水分含量>挤压温度,最佳工艺条件为SPI添加量10.23%(以400 g大米粉为基准)、水分含量25%和挤压温度133℃。将最优条件下制备的混合米粉与大米粉的吸水性指数、糊化特性和傅里叶红外光谱进行比较,表明混合米粉的吸水性指数远高于大米粉,糊化特性和短程有序程度均低于大米粉。混合米粉面条与大米粉面条相比干物质损失率和断条率有所下降,吸水率、感官评分、硬度、弹性和咀嚼性均升高。添加SPI的大米粉经挤压后制得混合米粉的吸水性和回生特性均有所改善,制作的混合米粉面条的蒸煮特性及感官品质较大米粉面条有显著的提升,不仅提高了大米粉的经济价值又利于促进稻米产业链的延伸,而且拓宽了以大米粉为原料的米制品在主食方面的应用范围。

Influence of soy protein isolate on the gel properties of walnut protein isolate-κ-carrageenan treated with NaCl

The demand for plant protein is increasing significantly due to the shortage of protein resources.Walnut protein,the main by-product of preparing walnut oil,has limited application in the food industry due to its poor solubility.It was found that the soy protein isolate(SPI)concentration had significant effects on the gel properties of the walnut protein isolate(WNPI)-κ-Carrageenan(KC)composite system treated with 15 mmol/L NaCl.The results showed that the gel strength of the composite system increased first and then decreased with the increased concentration of SPI from 0 to 2.5%.The best rheological properties,texture properties,water holding capacity((92.03±1.05)%),swelling ratio((2.04±0.19)%),freeze-thaw stability and thermal stability(85.53°C)of the composite gel were found at an SPI concentration of 1%.In the meantime,the secondary structure of protein had the least α-helix content of 10.17% and the highest β-sheet content of 39.64%,the fluorescence intensity and free sulfhydryl content reached the highest value.1% SPI could also act as a filler for WNPI to enhance the intermolecular forces such as hydrophobic interaction between the two substances,thus forming a stable gel network structure.This study can provide technical support for improving the gel properties of walnut protein and producing new plant protein gel products.

超声协同大豆分离蛋白对米粉和米面包品质的影响及机制研究

目的探究超声协同大豆分离蛋白(soybean isolate protein,SPI)对米粉以及米面包品质的影响。方法以碎米为主要原料,5个梯度(0%、3%、6%、9%、12%,以碎米粉质量计)的大豆分离蛋白(soybean isolate protein,SPI)为辅料,比较超声协同5个梯度SPI对混合粉热机械学特性、糊化特性、流变特性以及米面包比容、损耗率、感官评价的影响。结果与未进行超声处理的样品相比,超声协同SPI处理的米粉的吸水率从64.90±0.00增加至94.80±0.00,其混合粉的峰值黏度从2704.00±47.76降低至1567.00±116.73,表明超声使淀粉部分支链断裂,生成大量短直链淀粉,导致分子量下降,相互作用减弱;超声处理后的样品储能模量(G')曲线随着SPI含量的增加呈现出先降低后增加再降低的趋势,损耗模量(G")曲线呈现出逐渐降低的趋势。当SPI添加量为9%时,米面包的比容达到最大值,为(0.86±0.08)mL/g,感官评分从50.05±3.75增加至86.27±2.28;当SPI添加量达到12%时,米面包的损耗率达到最低。结论综上所述,采用9%SPI的方法制备米面包,可以有效地改善米面包品质,本研究为米面包在食品领域的应用提供了理论基础。

大豆分离蛋白对大豆肽纳米颗粒Pickering乳液性能的影响

为提高大豆肽纳米颗粒(SPN)Pickering乳液稳定性,以大豆肽聚集体为原料,采用超声法制备SPN,对超声时间进行了优化;在SPN体系中引入大豆分离蛋白(SPI)构建复合乳化剂,研究不同乳化剂质量浓度下SPI对SPN界面活性和乳化稳定性的影响。结果表明:选取超声时间10 min制备SPN;随着乳化剂质量浓度的增大,乳液粒径逐渐减小,当乳化剂质量浓度较低(5 mg/mL)时,乳液出现桥联,乳化剂质量浓度过高(30 mg/mL)时则出现絮凝;界面蛋白吸附率随着乳化剂质量浓度的增加呈现先升高后降低的趋势。在相同乳化剂质量浓度下,添加SPI的SPN乳液(SPI-SPN乳液)的粒径分布峰左移,其粒径、界面蛋白吸附率显著小于SPN乳液的;在储存过程中,SPN乳液粒径逐渐增大,SPI-SPN乳液粒径没有显著变化;SPI-SPN乳液的乳析指数小于相同乳化剂质量浓度的SPN乳液,当乳化剂质量浓度为30 mg/mL时,储存15 d SPI-SPN乳液未出现分层现象。综上,SPI可以提高SPN的界面活性和SPN乳液储存过程中的絮凝稳定性和分层稳定性。

大豆分离蛋白与黄原胶复合对胡麻油乳液及其模板油凝胶物理性质的影响

为了研究大豆分离蛋白与黄原胶复合制备胡麻油基油凝胶的潜力,采用乳液模板法,在大豆分离蛋白(质量分数5%)与黄原胶(质量分数0.5%)体积比为1∶1、2∶1、3∶1、5∶1、10∶1的条件下制备了胡麻油基油凝胶,考察黄原胶添加比例对乳液稳定性、凝胶强度、油损失率和二级结构的影响。结果表明:随着黄原胶添加比例的增加,乳液的物理稳定性和黏弹性增大,乳液粒径明显减小,最小为(2.99+0.29)μm,乳化稳定性比对照组增加了1.5倍,表现出类似固体的性质。当大豆分离蛋白与黄原胶的体积比为1∶1时,油凝胶的油损失率比纯大豆分离蛋白油凝胶减少了26.87%。当大豆分离蛋白与黄原胶的体积比为3∶1时,凝胶强度G′>11000Pa,明显大于未添加黄原胶的油凝胶(1900Pa)。通过对油凝胶二级结构进行分析,发现聚合物链内的氢键是聚合物油凝胶形成的重要驱动力。本研究为食品用聚合物制备油凝胶提供了参考,并为其替代固体脂肪的潜在应用提供了理论基础。

碱提酸沉参数影响大豆分离蛋白变性、聚集和流变特性的研究进展

pH值、NaCl和温度是制备大豆分离蛋白的重要参数。pH值和NaCl通过改变蛋白质表面电荷和静电斥力影响其聚集程度;温度通过改变蛋白质表面疏水性和/或二硫键影响其聚集程度,三者进而改变其颗粒大小或致密程度,引起流变性和下游应用特性的变化。本文从相互作用、热稳定性、聚集程度及胶凝特性等方面综述了pH值、NaCl和温度对大豆分离蛋白及其组分glycinin和β-conglycinin的变性、聚集和流变特性的影响,探讨了可能的机理;梳理了蛋白质聚集度、凝胶链粗厚度、凝胶链曲直率、凝胶网络连续性与凝胶强度之间的关系;总结了pH值、NaCl和温度对蛋白质聚集影响的差异。旨在为通过制备参数调控大豆分离蛋白聚集程度提供帮助。

淀粉醛强化大豆分离蛋白/槲皮素复合膜制备及性能研究

目的探究淀粉醛(dialdehyde starch,DAS)对大豆分离蛋白(soy protein isolate,SPI)/槲皮素(quercetin,QR)复合膜特性的影响。方法以青稞淀粉为原料,通过高碘酸钠氧化制备了DAS,以SPI为基质,以DAS和QR为添加物,以拉伸强度、水分阻隔性能、抗氧化性能为指标进行单因素试验,通过响应面优化试验筛选出DAS强化的SPI/QR复合膜最佳制备条件后,对复合膜的微观结构进行表征,并对其物理学性能进行测试。结果DAS强化的SPI/QR复合膜最佳制备条件为每100 mL蒸馏水中添加SPI 6.00 g、pH为8、DAS 5%、QR 4%、DES 25%(DAS、QR、DES以SPI质量计)。在此条件下,薄膜的拉伸强度为(7.37±0.39)MPa、水蒸气透过系数为(3.54±0.29)×10^(-11)g/(m·s·Pa)、抗氧化活性为(70.88±0.40)%。结构表征结果表明,DAS的添加使得该复合膜分子间形成了共价亚胺键,表面结构及横断面结构更加致密。此外,该复合膜具有较好的热稳定性、紫外阻隔性、疏水性。结论DAS处理改善了SPI/DAS/QR复合膜的内部结构,提高了复合膜的拉伸、耐水、抗氧化性能、热稳定、紫外阻隔、疏水性能。本研究可为基于SPI可生物降解薄膜的开发及应用提供参考。

HPAN/SPI水凝胶纤维的pH刺激响应性能

探索了聚丙烯腈(PAN)和大豆分离蛋白(SPI)在NaOH水溶液中进行PAN碱解,然后挤到凝固浴中凝固、交联,制备水解聚丙烯腈(HPAN)/SPI水凝胶纤维的方法。通过测定凝胶纤维的平衡溶胀伸长率和溶胀伸长率,观察到HPAN/SPI水凝胶纤维的滞后和可逆的伸长/收缩行为,同时在不同组成的凝胶纤维中,随着PAN含量的逐渐增大,水凝胶纤维的响应速率呈现由小到大然后减小的变化规律,当 mPAN /mSPI =6/4时有最好的响应性能。