Treatment of Wastewater with Modified Sequencing Batch Biofilm Reactor Technology

This paper describes the removal of COD and nitrogen from wastewater with modified sequencing batch biofilm reactor. The strategy of simultaneous feeding and draining was explored.The results show that introduction of a new batch of wastewater and withdrawal of the purified water can be conducted simultaneously with the maximum volumetric exchange rate of about 70%.Application of this feeding and draining mode leads to the reduction of the cycle time, the increase of the utilization of the reactor volume and the simplification of the reactor structure. The treatment of a synthetic wastewater containing COD and nitrogen was investigated. The operation mode of F(D) O ( i.e ., simultaneous feeding and draining followed by the aerobic condition) was adopted. It was found that COD was degraded very fast in the initial reaction period of time, then reduced slowly and the ammonia nitrogen and nitrate nitrogen concentrations decreased and increased with time respectively, while the nitrite nitrogen level increased first and then reduced. The relationship between the COD or ammonia nitrogen loading and its removal rate was examined, and the removal of COD, ammonia nitrogen and total nitrogen could exceed 95%, 90% and 80% respectively. The fact that nitrogen could be removed more completely under constant aeration (aerobic condition) of the SBBR operation mode is very interesting and could be explained in several respects.

Nitrous Oxide Production in a Sequence Batch Reactor Wastewater Treatment System Using Synthetic Wastewater

The rate of nitrous oxide emission from a laboratory sequence batch reactor （SBR） wastewater treatment system using synthetic wastewater was measured under controlled conditions. The SBR was operated in the mode of 4 h for aeration, 3.5 h for stirring without aeration, 0.5 h for settling and drainage, and 4 h of idle. The sludge was acclimated by running the system to achieve a stable running state as chemical oxygen demand, NO2^-, NO3^-, NH4^＋, pH, and N2O. indicated by rhythmic changes of total N, dissolved oxygen, Under the present experimental conditions measured nitrous oxide emitted from the off-gas in the aerobic and anaerobic phases, respectively, accounted for 8.6%-16.1% and 0-0.05% of N removed, indicating that the aerobic phase was the main source of N2O emission from the system. N2O dissolved in discharged water was considerable in term of concentration. Thus, measures to be developed for the purpose of reducing N2O emission from the system should be effective in the aeration phase.

treatment of swine wastewater in aerobic granular reactors： comparison of different seed granules as factors

The granulation process, physic-chemical properties, pollution removal ability and bacterial com- munities of aerobic granules with different feed-waste- water （synthetic wastewater, R1; swine wastewater, R2）, and the change trend of some parameters of two types of granules in long-term operated reactors treating swine wastewater were investigated in this experiment. The result indicated that aerobic granulation with the synthetic wastewater had a faster rate compared with swine waste- water and that full granulation in R 1 and R2 was reached on the 30th day and 39th day, respectively. However, although the feed wastewater also had an obvious effect on the biomass fraction and extracellular polymeric sub- stances of the aerobic granules during the granulation process, these properties remained at a similar level after long-term operation. Moreover, a similar increasing trend could also be observed in terms of the nitrogen removal efficiencies of the aerobic granules in both reactors, and the average specific removal rates of the organics and ammonia nitrogen at the steady-state stage were 35.33mg.g^-1 VSS and 51.46mg.g^-1 VSS for R1, and 35.47mg.g^-1 VSS and 51.72mg.g^-1 VSS for R2, respectively. In addition, a shift in the bacterial diversity occurred in the granulation process, whereas bacterial communities in the aerobic granular reactor were not affected by the seed granules after long-term operation.

Research Development and Application of Nitrogen and Phosphorus Removal in Sequencing Batch Biofilm Reactor

Frequent variations of the wastewater quality and quantity and other uncertain factors are the challenges faced by many wastewater treatment plants during the operation. Sequencing batch biofilm reactor（ SBBR） process provides a new idea for an effective solution to this problem. This paper introduces the basic processes and characteristics of the sequencing batch biofilm reactor（ SBBR） process,and summarizes the research status of this process in wastewater treatment. Factors affecting the nitrogen and phosphorus removal effect of the SBBR process are also analyzed.

Factors affecting biological denitrifying dephosphatation in anaerobic/anoxic/aerobic sequencing batch reactor

This study was conducted to verify and discuss the denitrifying dephosphatation under different levels of nitrate concentration and retention time of anoxic/aerobic process in a Sequencing Batch Reactor (SBR). The results of tests demonstrated that there were two kinds of phosphorus-accumulating organisms (PAOs) in the biological excess phosphorus removal (BEPR) system. One was non-DNPAOs that could only use oxygen as terminal electron acceptors, the other was denitrifying PAOs (DNPAOs) that could use both nitrate and oxygen as terminal electron acceptors. Phosphorus uptake efficiency could be attained under anoxic period ranging from 28.7%-96.7% in an anaerobic/anoxic/aerobic system. Experimental results showed that nitrate concentration and retention time of anoxic/aerobic process were the key factors affecting the course of denitrifying dephosphatation.

Characterization of the start-up period of single-step autotrophic nitrogen removal in a sequencing batch reactor

The characteristics of the start-up period of single-step autotrophic nitrogen removal process were investigated. The autotrophic nitrogen removal process used a sequencing batch reactor to treat wastewater of medium to low ammonia-nitrogen concentration, with dissolved oxygen （DO）, hydraulic retention time （HRT） and temperature controlled. The experimental conditions were temperature at （30±2） ℃, ammonia concentration of （60 to 120） mg/L, DO of （0.8 to 1.0） mg/L, pH from 7.8 to 8.5 and HRT of 24 h. The rates of nitrification and nitrogen removal turn out to be 77% and 40%, respectively, after a start up period going through three stages divided according to nitrite accumulation： sludge domestication, nitrifying bacteria selection and sludge adaptation, It is demonstrated that dissolved oxygen is critical to nitrite accumulation and elastic YJZH soft compound packing is superior to polyhedral hollow balls in helping the bacteria adhere to the membrane.

碱激活PMS氧化法协同SBBR深度处理焦化废水研究

采用碱激活过一硫酸盐(PMS)氧化法协同序批式生物膜反应器(SBBR)工艺深度处理焦化废水,研究当以NaOH作为激活剂时,pH、PMS浓度和温度对碱/PMS体系去除焦化废水生化出水COD和色度的影响,之后考察SBBR工艺处理碱/PMS体系出水的效果。研究结果表明,碱/PMS体系深度处理焦化废水的最佳条件为温度25℃、pH=10、PMS投加浓度7 mmol/L、反应时间4 h,在此条件下色度和COD的去除率分别为96.1%和45.9%。电子顺磁共振实验表明碱/PMS体系存在^(1)O_(2)、O_(2)•-、∙OH和SO_(4)•-等活性氧物种。废水经碱/PMS体系处理后可生化性提高,之后经SBBR工艺进一步处理后出水COD<60 mg/L。总体而言,碱激活PMS氧化法协同SBBR工艺对COD的平均去除率达66.7%。焦化废水生化出水处理前后的三维荧光光谱分析表明,碱/PMS体系协同SBBR工艺能去除焦化废水生化出水中的芳香蛋白类物质和类腐殖酸物质。

连续流反应器中好氧颗粒污泥快速培养研究进展

好氧颗粒污泥(aerobic granular sludge,AGS)是目前最有前景的污水生物处理技术之一,采用连续流反应器(continuous flow reactor,CFR)进行AGS快速培养的技术近年来受到广泛关注。文中通过综述间歇式反应器(sequencing batch reactor,SBR)工艺实现快速颗粒化的调控方法、CFR强化颗粒化及优化控制,总结了目前SBR工艺实现快速颗粒化的主要措施,以及采用基于SBR颗粒化的原理在CFR中实现快速颗粒化的可行方案,包括选择压优化、饱食/饥饿(feast/famine)条件以及晶核策略(crystal nucleus)等。最后对CFR工艺实现快速颗粒化的应用前景进行了展望,并提出探究SBR中强化颗粒化的策略,将有望在未来更加深入地研究AGS在CFR中的形成机理。

Effect of the C:N:P ratio on the denitrifying dephosphatation in a sequencing batch biofilm reactor(SBBR)

A series of investigations were conducted using sequencing batch biofilm reactor（SBBR） to explore the influence of C：N：P ratio on biological dephosphatation including the denitrifying dephosphatation and the denitrification process.Biomass in the reactor occurred mainly in the form of a biofilm attached to completely submerged disks.Acetic acid was used as the source of organic carbon.C：N：P ratios have had a significant effect on the profiles of phosphate release and phosphate uptake and nitrogen removal.The highest rates of phosphate release and phosphate uptake were recorded at the C：N：P ratio of 140：70：7.The C：N ratio of 2.5：1 ensured complete denitrification.The highest rate of denitrification was achieved at the C：N：P ratio of 140：35：7.The increase of nitrogen load caused an increase in phosphates removal until a ratio C：N：P of 140：140：7.Bacteria of the biofilm exposed to alternate conditions of mixing and aeration exhibited enhanced intracellular accumulation of polyphosphates.Also,the structure of the biofilm encouraged anaerobic-aerobic as well as anoxic-anaerobic and absolutely anaerobic conditions in a SBBR.These heterogeneous conditions in the presence of nitrates may be a significant factor determining the promotion of denitrifying polyphosphate accumulating organism（DNPAO） development.

Insights into a novel nitrogen removal process based on simultaneous anammox and denitrification(SAD) following nitritation with in-situ NOB elimination

Simultaneous anammox and denitrification(SAD) is an efficient approach to treat wastewater having a low C/N ratio;however, few studies have investigated a combination of SAD and partial nitritation(PN). In this study, a lab-scale up-flow blanket filter(UBF) and zeolite sequence batch reactor(ZSBR) were continuously operated to implement SAD and PN advantages, respectively. The UBF achieved a high total nitrogen(TN) removal efficiency of over 70% during the start-up stage(days 1–50), and reached a TN removal efficiency of 96%in the following 90 days(days 51–140) at COD/NH_(4)^(+)-N ratio of 2.5. The absolute abundance of anammox bateria increased to the highest value of 1.58 × 107copies/μL DNA;Comamonadaceae was predominant in the UBF at the optimal ratio. Meanwhile, ZSBR was initiated on day 115 as fast nitritation process to satisfy the influent requirement for the UBF. The combined process was started on day 140 and then lasted for 30 days, during the combined process, between the two reactors, the UBF was the main contributor for TN(66.5% ± 4.5%)and COD(71.8% ± 4.9%) removal. These results demonstrated that strong SAD occurred in the UBF when following a ZSBR with in-situ NOB elimination. This research presents insights into a novel biological nitrogen removal process for low C/N ratio wastewater treatment.

国内制革废水处理工艺研究现状

针对国内制革综合废水的处理研究,从一级物化处理和二级生化处理两个方面做了概括。就一级物化处理而言,介绍了国内制革废水处理的发展过程,并指出了制革废水处理的发展方向———绿色化学技术;在制革废水的二级处理工艺研究上,介绍了制革废水处理中的曝气工艺、氧化沟工艺、SBR工艺、生物膜等在国内制革废水处理上的理论及应用研究情况,针对国内制革企业普遍规模较小的特点,认为SBR工艺是较适于国内制革废水特点的处理工艺。

SBR中DO的变化及其作为污水处理控制参数的研究

序批式活性污泥法 (SBR)处理污水是一个好氧过程 ,需氧量与有机物的降解有关。反应器内溶解氧 (DO)的变化取决于进水的浓度、曝气量、污泥浓度等因素。试验研究表明 ,进水浓度高 ,需氧量大 ,反应时间长 ;供气量大 ,有机物降解快 ,反应时间短 ;污泥浓度 (MLSS)高 ,有机物降解快 ,反应时间短。而以上污水处理过程的特征都可以由反应器中DO的变化来反映 。

ASBR法处理酸性钛白废水的技术研究

采用厌氧序批式反应器 (ASBR)处理高浓度硫酸盐废水 ,取得了较好的效果 模拟废水和实际钛白粉废水的试验显示 ,硫酸根离子的去除率分别达到 92 .1% ,83.5 % COD SO42 -的比值对硫酸根离子去除率有较大影响 ,比值在 2～ 3时效果最佳 该试验工艺的一个特点是采用了气循环与水循环并用的方法 ,以防止硫化氢气体对硫酸盐还原菌 (SRB)的毒害 。

低温对MBBR、SBR深度处理废水出水水质的影响

比较了低温和常温下移动床生物膜反应器(MBBR)与SBR深度处理低浓度废水的出水水质,研究了低温对反应器出水COD、运行温度、DO、出水pH、出水蛋白质质量浓度的影响。实验结果表明:相同曝气和环境温度条件下,MBBR比SBR的运行温度高0.5～1.5℃,受环境温度影响更小;与常温相比,低温反应器内DO高约1.2mg/L;在低温条件下,MBBR容易出现酸化现象,SBR的pH保持正常;低温条件下MBBR出水蛋白质质量浓度高,蛋白质质量浓度随温度变化浮动较大,这对于MBBR出水水质造成一定影响。

SBR工艺的现状与发展

序批式间歇活性污泥法(SBR)是近年来应用日趋广泛的一种污水处理工艺,在SBR工艺的基础上,又发展了一些SBR的变型工艺,例如ICEAS工艺、CASS工艺、UNITANK工艺、ASBR工艺、BSBR工艺等。今后应加强SBR工艺中微生物的研究和可靠的工程设计模式的探讨。

采用两段SBR工艺处理石化废水

采用两段序批式活性污泥反应器(SBR)工艺处理高浓度石化废水,考察了DO、MLSS、反应温度对废水处理效果的影响。实验结果表明,两段SBR系统中有机物降解存在着不同的作用机理,第一段主要以去除易降解有机物为主,第二段主要以去除难降解有机物为主。在进水COD为4 000 mg/L、SBR1中DO为4～5 mg/L、MLSS为5 000 mg/L,SBR2中DO为2～4 mg/L、MLSS为3 000 mg/L、反应温度约为20℃的条件下,废水COD去除率达90%以上。

序批式反应器工艺的研究进展

回顾了序批式反应器(SBR)技术的发展历史,介绍了近20年来国内外SBR技术研究与应用的新发展,着重分析了其基本原理、技术优势和不足之处,指出SBR技术是一项极具竞争力的废水生物处理技术。

Fenton试剂氧化—SBR工艺处理阿莫西林制药废水生化处理出水

采用Fenton试剂氧化—SBR工艺处理阿莫西林制药废水生化处理出水。实验结果表明:当初始废水pH为3.0、H2O2加入量为10 mL/L、V(H2O2):m(FeSO4.7H2O)为5(mL):1(g)、Fenton试剂氧化反应时间为3 h时,Fenton试剂氧化COD去除率达72.25%,色度由100倍降为2倍,BOD5/COD由0.06提高到0.38,可生化性显著提高。经Fenton试剂氧化—SBR工艺处理后,出水COD为72.7 mg/L,达到国家排放标准。

DO对同步硝化反硝化协同除磷的影响

采用序批式活性污泥反应器（SBR）处理模拟城市污水，在厌氧一好氧运行方式下，考察了DO对同步硝化反硝化协同除磷效果的影响。结果表明，DO的变化对该系统中有机物的去除影响不显著，当DO为1．5～2．0mg／L时，TN及TP去除率均能达到90％以上，并可以应用pH曲线拐点来判断系统硝化过程是否完成。