In order to improve the ability of SCR catalyst to catalyze the oxidation of gaseous elemental mercury,a series of novel Ce modified SCR(Selection Catalytic Reduction,V_(2)O_(5)-WO_(3)/TiO_(2))catalysts were prepared ...In order to improve the ability of SCR catalyst to catalyze the oxidation of gaseous elemental mercury,a series of novel Ce modified SCR(Selection Catalytic Reduction,V_(2)O_(5)-WO_(3)/TiO_(2))catalysts were prepared via two-step ultrasonic impregnation method.The performance of Ce/SCR catalysts on Hg^(0)oxidation and NO reduction as well as the catalytic mechanism on Hg^(0)oxidation was also studied.The XRD,BET measurements and XPS were used to characterize the catalysts.The results showed that the pore volume and pore size of catalyst was reduced by Ce doping,and the specific surface area decreased with the increase of Ce content in catalyst.The performance on Hg^(0)oxidation was promoted by the introduction of CeO_(2).Ce_(1)/SCR(1%Ce,wt.%)catalyst exhibited the best Hg^(0)oxidation activity of 21.2%higher than that of SCR catalyst at 350℃,of which the NO conversion efficiency was also higher at 200-400℃.Furthermore,Ce_(1)/SCR showed a better H_(2)O resistance but a slightly weaker SO_(2)resistance than SCR catalyst.The chemisorbed oxygen and weak absorbed oxygen on the surface of catalyst were increased by the addition of CeO_(2).The chemisorbed oxygen and weak absorbed oxygen on the surface of catalyst were increased by the addition of CeO_(2).The Ce_(1)/SCR possed better redox ability compared with SCR catalyst.HCl was the most effective gas responsible for the Hg^(0)oxidation,and the redox cycle(V^(4+)+Ce^(4+)←→V^(5+)+Ce^(3+))played an important role in promoting Hg^(0)oxidation.展开更多
Ultra-low emission(ULE)technology retrofits significantly impact the particulate-bound mercury(Hg)emissions from coal-fired power plants(CFPPs);however,the distribution and bioavailability of Hg in size-fractioned par...Ultra-low emission(ULE)technology retrofits significantly impact the particulate-bound mercury(Hg)emissions from coal-fired power plants(CFPPs);however,the distribution and bioavailability of Hg in size-fractioned particulate matter(PM)around the ULE-retrofitted CF-PPs are less understood.Here,total Hg and its chemical speciation in TSP(total suspended particles),PM_(10)(aerodynamic particle diameter≤10μm)and PM_(2.5)(aerodynamic particle diameter≤2.5μm)around a ULE-retrofitted CFPP in Guizhou Province were quantified.Atmospheric PM_(2.5)concentration was higher around this ULE-retrofitted CFPP than that in the intra-regional urban cities,and it had higher mass Hg concentration than other sizefractioned PM.Total Hg concentrations in PM had multifarious sources including CFPP,vehicle exhaust and biomass combustion,while they were significantly higher in autumn and winter than those in other seasons(P<0.05).Regardless of particulate size,atmospheric PM-bound Hg had lower residual fractions(<21%)while higher HCl-soluble fractions(>40%).Mass concentrations of exchangeable,HCl-soluble,elemental,and residual Hg in PM_(2.5)were higher than those in other size-fractioned PM,and were markedly elevated in autumn and winter(P<0.05).In PM_(2.5),HCl-soluble Hg presented a significantly positive relationship with elemental Hg(P<0.05),while residual Hg showed the significantly positive relationships with HCl-soluble Hg and elemental Hg(P<0.01).Overall,these results suggested that atmospheric PM-bound Hg around the ULE-retrofitted CFPP tends to accumulate in finer PM,and has higher bioavailable fractions,while has potential transformation between chemical speciation.展开更多
Coal-fired utility boilers are now identified as the largest source of mercury in the United States. There is speculation that the installation of selective catalytic reduction （SCR） system for reduction of NOx can ...Coal-fired utility boilers are now identified as the largest source of mercury in the United States. There is speculation that the installation of selective catalytic reduction （SCR） system for reduction of NOx can also prompt the oxidation and removal of mercury. In this paper, tests at six full-scale power plants with similar type of the SCR systems are conducted to investigate the effect of the SCR on the transformation of mercury speciation. The results show that the SCR system can achieve more than 70%-80% oxidation of elemental mercury and enhance the mercury removal ability in these units. The oxidation of elemental mercury in the SCR system strongly depends on the coal properties and the operation conditions of the SCR systems. The content of chloride in the coal is the key factor for the oxidization process and the maximum oxidation of elemental mercury is found when chloride content changes from 400 to 600 ppm. The sulfur content is no significant impact on oxidation of elemental mercury.展开更多
The development history and major technological innovations of the ultra-low pressure naphtha reforming technology with continuous catalyst regeneration in China were introduced.This technology had been adopted by the...The development history and major technological innovations of the ultra-low pressure naphtha reforming technology with continuous catalyst regeneration in China were introduced.This technology had been adopted by the 1.0 Mt/a CCR unit at the Guangzhou Company.The appropriate catalyst was selected to meet the demand of the unit capacity,the feedstock,and the product slate.The design parameters,including the reaction pressure,the octane number of C5+liquid product,the reaction temperature,the space velocity,the hydrogen/oil molar ratio,and the catalyst circulating rate,were chosen based on the study of process conditions and parameters.The commercial test results showed that the research octane number of C5+product reached 104 when the capacity of the CCR unit was 100%and 115%of the design value.The other technical targets attained or exceeded the expected value.展开更多
Heterogeneous oxidation of gas-phase Hg 0 by nano-Fe 2 O 3 was investigated on a fixed bed reactor, and the effects of oxygen concentration, bed temperature, water vapour concentration and particle size have been disc...Heterogeneous oxidation of gas-phase Hg 0 by nano-Fe 2 O 3 was investigated on a fixed bed reactor, and the effects of oxygen concentration, bed temperature, water vapour concentration and particle size have been discussed. The results showed that Hg 0 could be oxidized by active oxygen atom on the surface of nano-Fe 2 O 3 as well as lattice oxygen in nano-Fe 2 O 3 . Among the factors that affect Hg 0 oxidation by nano-Fe 2 O 3 , bed temperature plays an important role. More than 40% of total mercury was oxidized at 300°C, however, the test temperature at 400°C could cause sintering of nano-catalyst, which led to a lower efficiency of Hg 0 oxidation. The increase of oxygen concentration could promote mercury oxidation and led to higher Hg 0 oxidation efficiency. No obvious mercury oxidation was detected in the pure N 2 atmosphere, which indicates that oxygen is required in the gas stream for mercury oxidation. The presence of water vapour showed different effects on mercury oxidation depending on its concentration. The lower content of water vapour could promote mercury oxidation, while the higher content of water vapour inhibits mercury oxidation.展开更多
基金This work was supported by the National Key Research and Development Program of China(No.2016YFB0600603).
文摘In order to improve the ability of SCR catalyst to catalyze the oxidation of gaseous elemental mercury,a series of novel Ce modified SCR(Selection Catalytic Reduction,V_(2)O_(5)-WO_(3)/TiO_(2))catalysts were prepared via two-step ultrasonic impregnation method.The performance of Ce/SCR catalysts on Hg^(0)oxidation and NO reduction as well as the catalytic mechanism on Hg^(0)oxidation was also studied.The XRD,BET measurements and XPS were used to characterize the catalysts.The results showed that the pore volume and pore size of catalyst was reduced by Ce doping,and the specific surface area decreased with the increase of Ce content in catalyst.The performance on Hg^(0)oxidation was promoted by the introduction of CeO_(2).Ce_(1)/SCR(1%Ce,wt.%)catalyst exhibited the best Hg^(0)oxidation activity of 21.2%higher than that of SCR catalyst at 350℃,of which the NO conversion efficiency was also higher at 200-400℃.Furthermore,Ce_(1)/SCR showed a better H_(2)O resistance but a slightly weaker SO_(2)resistance than SCR catalyst.The chemisorbed oxygen and weak absorbed oxygen on the surface of catalyst were increased by the addition of CeO_(2).The chemisorbed oxygen and weak absorbed oxygen on the surface of catalyst were increased by the addition of CeO_(2).The Ce_(1)/SCR possed better redox ability compared with SCR catalyst.HCl was the most effective gas responsible for the Hg^(0)oxidation,and the redox cycle(V^(4+)+Ce^(4+)←→V^(5+)+Ce^(3+))played an important role in promoting Hg^(0)oxidation.
基金supported by the Science and Technology Project of Guizhou Province(No.QKHJC[2020]1Y187)the National Natural Science Foundation of China(Nos.41265008,42007305,and 22166009)。
文摘Ultra-low emission(ULE)technology retrofits significantly impact the particulate-bound mercury(Hg)emissions from coal-fired power plants(CFPPs);however,the distribution and bioavailability of Hg in size-fractioned particulate matter(PM)around the ULE-retrofitted CF-PPs are less understood.Here,total Hg and its chemical speciation in TSP(total suspended particles),PM_(10)(aerodynamic particle diameter≤10μm)and PM_(2.5)(aerodynamic particle diameter≤2.5μm)around a ULE-retrofitted CFPP in Guizhou Province were quantified.Atmospheric PM_(2.5)concentration was higher around this ULE-retrofitted CFPP than that in the intra-regional urban cities,and it had higher mass Hg concentration than other sizefractioned PM.Total Hg concentrations in PM had multifarious sources including CFPP,vehicle exhaust and biomass combustion,while they were significantly higher in autumn and winter than those in other seasons(P<0.05).Regardless of particulate size,atmospheric PM-bound Hg had lower residual fractions(<21%)while higher HCl-soluble fractions(>40%).Mass concentrations of exchangeable,HCl-soluble,elemental,and residual Hg in PM_(2.5)were higher than those in other size-fractioned PM,and were markedly elevated in autumn and winter(P<0.05).In PM_(2.5),HCl-soluble Hg presented a significantly positive relationship with elemental Hg(P<0.05),while residual Hg showed the significantly positive relationships with HCl-soluble Hg and elemental Hg(P<0.01).Overall,these results suggested that atmospheric PM-bound Hg around the ULE-retrofitted CFPP tends to accumulate in finer PM,and has higher bioavailable fractions,while has potential transformation between chemical speciation.
基金Project supported by the National Basic Research Program (973) of China (No. 2006CB2003)the Scientific Research Foundation for the Returned Overseas Chinese Scholars, State Personnel Ministry.
文摘Coal-fired utility boilers are now identified as the largest source of mercury in the United States. There is speculation that the installation of selective catalytic reduction （SCR） system for reduction of NOx can also prompt the oxidation and removal of mercury. In this paper, tests at six full-scale power plants with similar type of the SCR systems are conducted to investigate the effect of the SCR on the transformation of mercury speciation. The results show that the SCR system can achieve more than 70%-80% oxidation of elemental mercury and enhance the mercury removal ability in these units. The oxidation of elemental mercury in the SCR system strongly depends on the coal properties and the operation conditions of the SCR systems. The content of chloride in the coal is the key factor for the oxidization process and the maximum oxidation of elemental mercury is found when chloride content changes from 400 to 600 ppm. The sulfur content is no significant impact on oxidation of elemental mercury.
基金Financial support form the SINOPEC Research Program(No.107025)
文摘The development history and major technological innovations of the ultra-low pressure naphtha reforming technology with continuous catalyst regeneration in China were introduced.This technology had been adopted by the 1.0 Mt/a CCR unit at the Guangzhou Company.The appropriate catalyst was selected to meet the demand of the unit capacity,the feedstock,and the product slate.The design parameters,including the reaction pressure,the octane number of C5+liquid product,the reaction temperature,the space velocity,the hydrogen/oil molar ratio,and the catalyst circulating rate,were chosen based on the study of process conditions and parameters.The commercial test results showed that the research octane number of C5+product reached 104 when the capacity of the CCR unit was 100%and 115%of the design value.The other technical targets attained or exceeded the expected value.
基金supported by the Scientific Funds for Outstanding Young Scientists of China(No.50525619)the National Natural Science Foundation of China(No.51078163,50706014)the National High Technology Research and Development Program(863)of China(No.2006AA05Z304)
文摘Heterogeneous oxidation of gas-phase Hg 0 by nano-Fe 2 O 3 was investigated on a fixed bed reactor, and the effects of oxygen concentration, bed temperature, water vapour concentration and particle size have been discussed. The results showed that Hg 0 could be oxidized by active oxygen atom on the surface of nano-Fe 2 O 3 as well as lattice oxygen in nano-Fe 2 O 3 . Among the factors that affect Hg 0 oxidation by nano-Fe 2 O 3 , bed temperature plays an important role. More than 40% of total mercury was oxidized at 300°C, however, the test temperature at 400°C could cause sintering of nano-catalyst, which led to a lower efficiency of Hg 0 oxidation. The increase of oxygen concentration could promote mercury oxidation and led to higher Hg 0 oxidation efficiency. No obvious mercury oxidation was detected in the pure N 2 atmosphere, which indicates that oxygen is required in the gas stream for mercury oxidation. The presence of water vapour showed different effects on mercury oxidation depending on its concentration. The lower content of water vapour could promote mercury oxidation, while the higher content of water vapour inhibits mercury oxidation.
